The URL can be used to link to this page

Home My WebLink AboutPermit M09-076 - GATEWAY - BUILDING 7GATEWAY BLDG 7 12720 GATEWAY DR M09 -076 Parcel No.: Address: Suite No: Contact Person: Name: Address: 2716000070 12720 GATEWAY DR TUKW Value of Mechanical: 127,796.00 Type of Fire Protection: Furnace: <100K BTU >100K BTU Floor Furnace Suspended/Wall/Floor Mounted Heater Appliance Vent Repair or Addition to Heat /Refrig /Cooling System.... Air Handling Unit <10,000 CFM >10,000 CFM Evaporator Cooler Ventilation Fan connected to single duct Ventilation System Hood and Duct Incinerator: Domestic Conunercial/Industrial doc: IMC-10/06 Citylif Tukwila Tenant: Name: GATEWAY BLDG 7 Address: 12720 GATEWAY DR , TUKWILA WA Department of Community Development 6300 Southcenter Boulevard, Suite #100 Tukwila, Washington 98188 Phone: 206 - 431 -3670 Fax: 206 -43I -3665 Web site: http://www.ci.tukwila.wa.us Owner: Name: RREEF AMERICA REIT II CORP/ Address: PO BOX 4900 #207 , SCOTTSDALE AZ CHRIS LEE 7717 DETROIT AV SW , SEATTLE WA Contractor: Name: MACDONALD /MILLER FAC SOL INC Address: PO BOX 47983 , SEATTLE, WA Contractor License No: MACDOFS980RU MECHANICAL PERMIT EQUIPMENT TYPE AND OUANTITY 0 0 0 0 0 0 1 0 0 0 0 0 0 0 * *continued on next page ** M09 -076 DESCRIPTION OF WORK: REPLACE (1) PACKAGED ROOFTOP UNIT, RECONNECT NATURAL GAS LINE TO ROOFTOP UNIT, REPLACE (37) VVT BOXES, INSTALL (1) PARALLEL VAV BOX AND MISC DUCTWORK. (RENEWAL OF EXPIRED PERMIT M08 -154) Permit Number: M09 -076 Issue Date: 06/30/2009 Permit Expires On: 12/27/2009 Phone: Phone: 206 768 -4266 Phone: 206 - 768 -4180 Expiration Date: 12/31/2010 Fees Collected: $1,511.37 International Mechanical Code Edition: 2006 Boiler Compressor: 0 -3 HP /100,000 BTU 0 3 -15 HP /500,000 BTU 0 15 -30 HP /1,000,000 BTU.. 0 30 -50 HP /1,750,000 BTU.. 0 50+ HP/1,750,000 BTU 0 Fire Damper 0 Diffuser 0 Thermostat 0 Wood/Gas Stove 0 Water Heater 0 Emergency Generator 0 Other Mechanical Equipment 38 Printed: 06 -30 -2009 Permit Center Authorized Signature: I hereby certify that I have read and examined this permit and know the same to be true and correct. All provisions of law and ordinances governing this work will be complied with, whether specified herein or not. The granting of t ' 't does not presume to give authority to violate or cancel the provisions of any other state or local laws regulating construction or a perform a of work. I a orized to sign and obtain this mechanical permit. Signature: Print Name: doc: I MC -10/06 • City of Tukwila Department of Community Development 6300 Southcenter Boulevard, Suite #100 Tukwila, Washington 98188 Phone: 206 - 431 -3670 Fax: 206 - 431 -3665 Web site: http: / /www.ci.tukwila.wa.us Permit Number: M09 -076 Issue Date: 06/30/2009 Permit Expires On: 12/27/2009 Date: 6:30-07 Date: b v CD c 1 This permit shall become null and void if the work is not commenced within 180 days from the date of issuance, or if the work is suspended or abandoned for a period of 180 days from the last inspection. M09 -076 Printed: 06 -30 -2009 Parcel No.: 2716000070 Address: Suite No: Tenant: 12720 GATEWAY DR TUKW GATEWAY BLDG 7 1: ** *BUILDING DEPARTMENT CONDITIONS * ** • City of Tukwila Department of Community Development 6300 Southcenter Boulevard, Suite #100 Tukwila, Washington 98188 Phone: 206 - 431 -3670 Fax: 206 - 431 -3665 Web site: http: / /www.ci.tukwila.wa.us PERMIT CONDITIONS Permit Number: Status: Applied Date: Issue Date: M09 -076 ISSUED 06/17/2009 06/30/2009 2: No changes shall be made to the approved plans unless approved by the design professional in responsible charge and the Building Official. 3: All permits, inspection records, and approved plans shall be at the job site and available to the inspectors prior to start of any construction. These documents shall be maintained and made available until final inspection approval is granted. 4: All construction shall be done in conformance with the approved plans and the requirements of the International Building Code or International Residential Code, International Mechanical Code, Washington State Energy Code. 5: All plumbing and gas piping work shall be inspected and approved under a separate permit issued by the Cityof Tukwila Permit Center. 6: All electrical work shall be inspected and approved under a separate permit issued by the City of Tukwila Building Department (206- 431 - 3670). 7: VALIDITY OF PERMIT: The issuance or granting of a permit shall not be construed to be a permit for, or an approval of, any violation of any of the provisions of the building code or of any other ordinances of the City of Tukwila. Permits presuming to give authority to violate or cancel the provisions of the code or other ordinances of the City of Tukwila shall not be valid. The issuance of a permit based on construction documents and other data shall not prevent the Building Official from requiring the correction of errors in the construction documents and other data. 8: ** *FIRE DEPARTMENT CONDITIONS * ** 9: The attached set of building plans have been reviewed by the Fire Prevention Bureau and are acceptable with the following concerns: 10: H.V.A.C. units rated at greater than 2,000 cfm require auto - shutdown devices. These devices shall be separately zoned in the alarm panel and local U.L. central station supervision is required. (City Ordinance #2051) 11: H.V.A.C. systems supplying air in excess of 2,000 cubic feet per minute to enclosed spaces within buildings shall be equipped with an automatic shutoff. Automatic shutoff shall be accomplished by interrupting the power source of the air- moving equipment upon detection of smoke in the main return -air duct served by such equipment. Smoke detectors shall be labeled by an approved agency for air -duct installation and shall be installed in accordance with the manufacturer's installation instructions. (IMC 606.1, 606.2.1) 12: Remote indicator lights are required on all above ceiling smoke detectors. (City Ordinance #2051) 13: Duct smoke detectors shall be capable of being reset from a single point near the alarm panel. (City Ordinance #2051) 14: Duct detectors shall send a supervisory signal only upon activation. (City Ordinance #2051) 15: All new fire alarm systems or modifications to existing systems shall have the written approval of The Tukwila Fire Prevention Bureau. No work shall commence until a fire department permit has been obtained. (City Ordinance #2051) (IFC doc: Cond -10/06 M09 -076 Printed: 06 -30 -2009 104.2) • • City of Tukwila Department of Community Development 6300 Southcenter Boulevard, Suite #100 Tukwila, Washington 98188 Phone: 206 - 431 -3670 Fax: 206 - 431 -3665 Web site: http. / /www.ci.tukwila.wa.us 16: Art electrical permit from the City of Tukwila Building Department Permit Center (206- 431 -3670) is required for this project. 17: Contact The Tukwila Fire Prevention Bureau to witness all required inspections and tests. (City Ordinances #2050 and #2051) 18: Any overlooked hazardous condition and/or violation of the adopted Fire or Building Codes does not imply approval of such condition or violation. 19: These plans were reviewed by Inspector 511. If you have any questions, please call Tukwila Fire Prevention Bureau at (206)575 -4407. doc: Cond -10/06 * *continued on next page ** M09 -076 Printed: 06 -30 -2009 • City of Tukwila Department of Community Development 6300 Southcenter Boulevard, Suite #100 Tukwila, Washington 98188 Phone: 206 - 431 -3670 Fax: 206 - 431 -3665 Web site: http: / /www.ci.tukwila.wa.us I hereby certify that I have read these conditions and will comply with them as outlined. All provisions of law and this work will be complied with, whether specified herein or not. The granting of this permit does not presume to give authority to violate or cancel the provision of any other work construction or the performance of work. Signature: Date: ( O - 3 J— O Print Name: doc: Cond -10/06 M09 -076 ordinances governing or local laws regulating Printed: 06 -30 -2009 Name: CHRIS LEE low CITY OF TUKWILA Community Development Department Permit Center 6300 Southcenter Blvd., Suite 100 Tukwila, WA 98188 htto://www.ci.tukwila.wa.us Site Address: 12720 GATEWAY DR TUKWILA, WA Tenant Name: GATEWAY BLDG 7 Property Owners Name: RREEF AMERICA REIT II CORP Mailing Address: PO BOX 4900 #270 E -Mail Address: Company Name: MACDONALD MILLER Mailing Address: 7717 DETROIT AVE SW Contact Person: STEVE FLINK E - Mail Address: STEVE.FLINK@MACMILLER.COM Contractor Registration Number: MACDOFS980RU N/A Company Name: CHRIS LEE Mailing Address: 7717 DETROIT AVE SW CHRIS LEE Contact Person: E - Mail Address: CHRIS.LEE @MACMILLER.COM H:\Applications \Forms - Applications On Line\2009 Applications \I -2009 - Mechanical Permit Application.doc Revised: 1-2009 bh MECHANICAL PERMIT APPLICATION Applications and plans must be complete in order to be accepted for plan review. Applications will not be accepted through the mail or by fax. * *Please Print ** SITE LOCATION King Co Assessor's Tax No.: 2716000070 Suite Number: SCOTTSDALE City New Tenant: AZ Day Telephone: (206) 768 - 4266 Floor: ❑ Yes ..No State Zip 0g0W be your permit i>g ready to be CONTACT PERSON Mailing Address: 7717 DETROIT AVE SW SEATTLE WA 98106 City State Zip Fax Number: MECHANICAL CONTRACTOR INFORMATION SEATTLE City Day Telephone: Fax Number: Expiration Date: WA 98106 State (253) 680 -3172 (253) 680 -3173 12/31/2009 All plans must be vet sta ARCHITECT OF RECO hitect of Recc Company Name: Mailing Address: City Contact Person: Day Telephone: E -Mail Address: Fax Number: State WA State (206) 768 -4266 Zip Zip ord ENGINEER OF. RECORD must be we amped by ; ngineer of p SEATTLE City Day Telephone: Fax Number: 98106 Zip Page 1 of 2 Unit Type: Qty Unit Type: . Qty. Unit Type: Qty Boiler /Compressor: Qty Furnace <100K BTU Air Handling Unit >10,000 CFM Fire Damper 0 -3 HP /100,000 BTU Furnace >100K BTU Evaporator Cooler Diffuser 3 -15 HP /500,000 BTU Floor Fumace Ventilation Fan Connected to Single Duct Thermostat 15 -30 HP /1,000,000 BTU Suspended/Wall/Floor Mounted Heater Ventilation System Wood/Gas Stove 30 -50 HP /1,750,000 BTU Appliance Vent Hood and Duct Emergency Generator 50 +HP /1,750,000 BTU Repair or addition to Heat/Refrig/Cooling System Incinerator — Domestic Other Mechanical Equipment 38 Air Handling Unit <10,000 CFM 1 Incinerator — Comm/Ind Valuation of Project (contractor's bid price): $ 1 27,796 Scope of Work (please provide detailed information): REPLACE (1) PACKAGED ROOFTOP UNIT, RECONNECT NATURAL GAS LINE TO ROOFTOP UNIT, REPLACE (37) VVT BOXES, INSTALL (1) PARALLEL VAV BOX AND CainOal AAVb- � ') MISC DUCTWORK. Use: Residential: New ❑ Replacement ❑ Commercial: New ❑ Replacement Fuel Type: Electric • • Indicate type of mechanical work being installed and the quantity below: Gas ® Other: Value of Construction — In all cases, a value of construction amount should be entered by the applicant. This figure will be reviewed and is subject to possible revision by the Permit Center to comply with current fee schedules. Expiration of Plan Review — Applications for which no permit is issued within 180 days following the date of application shall expire by limitation. The Building Official may grant one extension of time for additional periods not to exceed 90 days each. The extension shall be requested in writing and justifiable cause demonstrated. Section 105.3.2 International Building Code (current edition). I HEREBY CERTIFY THAT I HAVE READ AND EXAMINED THIS APPLICATION AND KNOW THE SAME TO BE TRUE UNDER PENALTY OF PERJURY BY THE LAWS OF THE STATE OF WASHINGTON, AND I AM AUTHORIZED TO APPLY FOR THIS PERMIT. BUILDING OWNER OR AUTHORIZED AGENT: Signature: Print Name: DARLA DOLL Mailing Address: 7717 DETROIT AVE SW Date Application Accepted: D4� H:Wpplications \Forms - Applications On Line\2009 Apphcanons \1 -2009 - Mechanical Permit Application.doc Revised: 1-2009 bh SEATTLE City Date: 06/16/2009 ay Telephone: (206) 768 -4278 WA 98106 State Staff Initials: Zip Date Application Expires: Page 2 of 2 RECEIPT NO: R09 -00908 Initials: JEM SET TRANSACTIONS: Set Member M09 -076 M09 -077 TOTAL: ACCOUNT ITEM LIST: Description MECHANICAL - NONRES Ci, of Tukwila. Department of Community Development 6300 Southcenter Boulevard, Suite #100 Tukwila, Washington 98188 Phone: 206 - 431 -3670 Fax: 206 - 431 -3665 Web site: http://www.ci.lukwila.wa. us SET RECEIPT Copy Reprinted on 06 -17 -2009 at 13:03:16 06/17/2009 Payee: MACDONALD- MILLER FACILITY SOLUTIONS, INC. Amount 604.55 381.82 604.55 • Payment Date: 06/17/2009 User ID: 1165 Total Payment: 986.37 SET ID: S000001250 SET NAME: MACDONALD MILLER TRANSACTION LIST: Type Method Description Amount Payment Check 2158 986.37 TOTAL: 986.37 Account Code Current Pmts 000.322.102.00.0 986.37 TOTAL: 986.37 PAYMENT RECEIVED Project: C hu/1/ C�;�� 7 Ty e o f Inspection: �.n,a ,e- Ssf1.7 Address: Date Called: Special Instructions: 94,71 , p� P /i/4/ Date anted: eD"• 3 d d5 p.m. Requester: Phone No: �y ,,,2.5"..3 -- fo- O .- 3 /7 COMMENTS: S ,P/0 /c l/ "1JcL / J afig,/ 7 ',2 i, 7' , p� P /i/4/ 7 .2.) lnspe $ .00 REINSPECTION FE aid at 6300 Southcenter Receipt No.: INSPECTION RECORD Retain a copy with permit INSPECTION NO. CITY OF TUKWILA BUILDING DIVISION 6300 Southcenter Blvd., #100, Tukwila, WA 98188 Date: D ?G PE NO. (206)431 -367 Approved per applicable codes. ❑ Corrections required prior to approval. 3d ED. Prior to inspection, fee must be uite 100. Call to schedule reinspection. COMMENTS: p4 , Type of Inspection: s — 5h177 =13°144 Address: /-27.20 rre6' Date Called: Special Instructions: 7 � , � Date Waived: Da 92�.F TJ IC / �iAr ✓I • :Y l T?IS i / SSA . 466 /d'1 714/ /� / Y LA 1 r r w. % N. Project: C B // -7 Type of Inspection: s — 5h177 =13°144 Address: /-27.20 rre6' Date Called: Special Instructions: 7 � , � Date Waived: Da 92�.F a. . P .m. Requester: Phone No: - 2 Y 66'o -J3'7 INSPECTION NO. El Approved per applicable codes. INSPECTION RECORD Retain a copy with permit PERMIT NO. CITY OF TUKWILA BUILDING DIVISION Southcenter Blvd., #100, Tukwila, WA 98188 (206)431 -3 El Corrections required prior to approval. .00 REINSPECTION F E- REQUIRED. Prior to inspection, fed must be aid at 6300 Southcenter lvd., Suite 100. Call to schedule reinspection. 1 Receipt No.: Date: COMMENTS: /9,_ .k) - -» / .. ;444✓ Date Called: Special Instructions: .®- 146JFQfl s 22 1 /CA, ii i i- • re- (. Date Wanted: 7 :21- !) 5' 7 i Requester: Phone No: ,?v, -.. 6 - /C55 ;- N� / /1/P ."4eo, )/id/ bile 7;- c) 1e), i if(1)1/ f MJ 9-/ N Project: Type of Inspection: R ept " )..... Address: �.,Q 7. .20 ;444✓ Date Called: Special Instructions: Date Wanted: 7 :21- !) 5' p.m. Requester: Phone No: ,?v, -.. 6 - /C55 INSPECTION NO. INSPECTION RECORD Retain a copy with permit /ML - -d7,4 PERMIT NO. CITY OF TUKWILA BUILDING DIVISION ;r2g. 6300 Southcenter Blvd., #100, Tukwila, WA 98188 (206)431 -3 N Approved per applicable codes. El Corrections required prior to approval. 7 Date,, /- v � r to inspection, fee must be ll to schedule reinspection. Date: .00 REINSPECTION EE REQUI D. Prior at 6300 Southcenter Blvd., Suite 100. Ca COMMENTS: `c? / l' ) Ai 2,- ,....././ ,-;),,...,,,, L.._ - r `..? I/ Type of Inspection: Address: Suite #: 1 ) 1----; Special Instructions: Phone No.: Project: ,C.,, -rt iN/o, '..1 `c? 0 67 7 Type of Inspection: Address: Suite #: 4 ; ' f :7:-k Contact Person: Special Instructions: Phone No.: Needs Shift Inspection: Sprinklers: Fire Alarm: Hood & Duct: Monitor: Pre-Fire: Permits: Occupancy Type: INSPECTION NUMBER INSPECTION RECORD Retain a copy with permit CITY OF TUKWILA FIRE DEPARTMENT 444 Andover Park East, Tukwila, Wa. 98188 206-575-4407 Approved per applicable codes. Inspector: Date: Hrs.: $80.00 REINSPECTION FEE REQUIRED. You will receive an invoice from 7 the City of Tukwila Finance Department. Call to schedule a reinspection. Word/Inspection Record Form.Doc 1/13/06 pi) a 4_," ).26 PERMIT NUMBERS Corrections required prior to approval. T.F.D. Form F.P. 113 Project: - r — iE c ► i . 'T - . Type of Inspection: - Address: i2'7a.® 6A-re Suite #: 1, -v "'�-,� Contact Person: S (tit n�4,. WA 14 c. ,c Special Instructions: Phone No.: �'b 39( -5'b5 Needs Shift Inspection: Q Sc,ro Sprinklers: Fire Alarm: J Hood & Duct: Monitor: 'J A . tk.,cro .T, Pre- Fire: ? ,a° Permits:. Occupancy Type: INSPECTION NUMBER PERMIT NUMBERS CITY OF TUKWILA FIRE DEPARTMENT 444 Andover Park East, Tukwila, j Wa. 98188 206 -575- Approved per applicable codes. Inspector: / U/ S hf Word /Inspection Record Form.Doc INSPECTION RECORD Retain a copy with permit I llate: 122 07 - 0tbrrections required prior to approval. COMMENTS: Elbe. - 4144 4 r ./C - r� „-- Ivni /7 ( 7itPt vi orty {-aie • Hrs.: $ 0.00 REINSPECTION FEE REQUIRED. You will receive an invoice from ity of Tukwila Finance Department. Call to schedule a reinspection. 1/13/06 T.F.D. Form F.P. 113 1�" STARTUP: ELECTRICAL SUPPLY VOLTAGE L1 -L2 51J 0 COMPRESSOR AMPS COMPRESSOR NO. 1 COMPRESSOR AMPS — COMPRESSOR NO. 2 SUPPLY FANS AMPS (CV) COOLING SUPPLY AIR GAS HEAT SUPPLY AIR ELECTRIC HEAT SUPPLY AIR PRESSURES GAS'INLET PRESSURE GAS ^MANIFOLD PRESSURE REFRIGERANT SUCTION REFRIGERANT DISCHARGE Copyright 2004 Carrier Corporation F F (48A ONLY) F (50A ONLY, IF EQUIPPED) IN. WG (48A ONLY) STAGE NO. 1 3;'"5 IN. WG CIRCUIT NO. 1 6 PSIG CIRCUTT NO. 2 '0_77 PSIG VERIFY REFRIGERANT CHARGE. 6 -ceate-(-treyi 8/ 4 -7 McJ-- UNIT START-UP CHECKLIST (VAV) 220 *VAV fan supply amps reading must be takeniwith a true RMS meter for accurate readings. TEMPERATURES OUTDOOR -AIR TEMPERATURE 5S F DB (Dry Bulb) RETURN -AIR TEMPERATURE (7 'F DB �' F WB (Wet Bulb) MODEL NO.: 4eA 1= TDs0 61101 I M SERIAL NO.: S I O U,31�1�12 SOFTWARE VERSION TECHNICIAN: biel DYl WGt + 4'S DATE: 2 25101 /1 e c S 1z 17/ 3 y3— ey° / — c3 5 c as ki 3 I z o (-00 PRE - STARTUP: EcB/ �6 R (3 i2y 9 o l - 0 VERIFY THAT DIP SWITCH SETTINGS ARE CORRECT' I ?-y 01-0 1 A-1 rn ©'VERIFY THAT ALL PACKING MATERIALS HAVE. BEEN REMOVED FROM UNIT C Y EMOVE ALL COMPRESSOR SHIPPING HOLDDOWN BOLTS AND BRACKETS PER INSTRUCTIONS 9VERIFY INSTALLATION OF ECONOMIZER HOOD EKERIFY INSTALLATION OF ALL OPTIONS AND ACCESSORIES III THAT ALL ELECTRICAL CONNECTIONS AND TERMINALS ARE TIGHT CHECK GAS PIPING FOR LEAKS (48A ONLY) Er THAT RETURN -AIR FILTER AND OUTDOOR -AIR FILTERS ARE CLEAN AND IN PLACE IB ERIFY THAT UNIT IS LEVEL WITHIN TOLERANCES FOR PROPER CONDENSATE DRAINAGE — HECK FAN WHEELS AND PROPELLERS FOR LOCATION IN HOUSING /ORIFICE, AND SETSCREW IS TIGHT IDI VERIFY THAT FAN SHEAVES ARE ALIGNED AND BELTS ARE PROPERLY TENSIONED VERIFY THAT SUCTION, DISCHARGE, AND LIQUID SERVICE VALVES ON EACH CIRCUIT ARE OPEN Dr THAT CRANKCASE HEATERS HAVE BEEN ON 24 HOURS BEFORE STARTUP. S L2 -L3 Y76 L3 -L1 4 /7? L1 I/ ./ / L2 /_(2/t/ L2 _____ Ll ////7. L2 (i L2 EXHAUST FAN AMPS 3. Y. 4 3 , STAGE NO. 2 .7, .S IN. WG (48A ONLY) CIRCUIT NO. 2 6 PSIG CIRCUIT NO. 2 '5 PSIG Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without Incurring obligations. • Book 11 1 PC 111 Catalog No. 834 -802013 Printed In U.S.A. Form 48/50A -2T Pg CL -10 1 -04 Replaces: New Tab I1a,1b 01 -0g nn•• •,UNJJT "START'UP CHECKL'1S•T , MODEL NO.: aIc Pc3 "vO � P5V G \ 1 3 SERIAL NO.: � U \,y 0 Cp SOFTWARE g VE SION TECHNICIAN: C (\ '}Ibfl DATE:¢ 048 PRE-START-UP: 1• VERIFY THAT DIP SWITCH SETTINGS ARE CORRECT VERIFY THAT ALL PACKING MATERIALS FIAVE BEEN REMOVED FROM UNIT REMOVE ALL COMPRESSOR SHIPPING HOLDDOWN BOLTS AND BRACKETS PER INSTRUCTIONS 'I VERIFY INSTALLATION OF ECONOMIZER HOOD ret VERIFY INSTALLATION OF ALL OPTIONS AND ACCESSORIES YIN CbDc.ca 42 VERIFY THAT ALL ELECTRICAL CONNECTIONS AND TERMINALS ARE TIGHT IA CHECK GAS PIPING FOR LEAKS (48A ONLY) !! CHECK THAT RETURN -AIR FILTER AND OUTDOOR -AIR FILTERS ARE CLEAN AND IN PLACE `f; VERIFY THAT UNIT IS LEVEL WITHIN TOLERANCES FOR PROPER CONDENSATE DRAINAGE ` 1 CHECK FAN WHEELS AND PROPELLERS FOR LOCATION IN HOUSING /ORIFICE, AND SETSCREW IS TIGHT re VERIFY THAT FAN SHEAVES ARE ALIGNED AND BELTS ARE PROPERLY TENSIONED V VERIFY THAT SUCTION, DISCHARGE, AND LIQUID SERVICE VALVES ON EACH CIRCUIT ARE OPEN Id VERIFY THAT CRANKCASEHEATERS.HAVE BEEN,ON 24.T- JOI : IRSBEFORE START-UP STARTUP: ELECTRICAL SUPPLY VOLTAGE L1 -L2 AGS L2 -L3 COM'R.ESSOP. AMPS — COMPRESSOR NO. 1 LI COMPRESSOR AMPS — COMPRESSOR NO. 2 LI SUPPLY FANS ,A..MPS (CV) (VAV) O VERIFY REFRIGERANT CHARGE: 15x5 X 5.5 (D F DB (Diy Bulb) L3 -LI L2 L2 EXHAUST FAN AMPS "VAV fan supply'cinps reading must be taken With a t;ueRMS meter for accurate readings. TEMPERATURES • OT.ITDOOR -AIR TEMPERATURE kETURN -AIR TENLPERATURE COOLING SUPPLY AIR GAS HEAT SUPPLY AIR ELECTRIC HEAT SUPPLY AIR PRESSURES GAS INLET PRESSURE GAS MANIFOLD PRESSURE REFRIGERANT SUCTION REFRIGERANT DISCHARGE ` • F DB F WB (!et Bulb) e �t,� . Nc� 1c ce13 L3 L3 \; t6.y « V 16.9 k F (48A ONLY) F (50A ONLY, IF EQUIPPED) • _� 0 I TIC. WG (48A ONLY) STAGE NO. 1 IN. WO STAGE NO. 2 IN. VJG (48A ONLY) CIRCUIT NO. 1 PSIG CIRC'JITNO.2 \ , PSIG CIRCUIT NO. 2' .1 PSIG CIRCUIT NO. 2 .\ Y PSIG Copyngta OQ7 Carrier Corporation Manufacturer r3139ii•ne tlin right to discontinue, or change at any tine speclflcat!one or designs without notice and without Incurring obligations. Book 1 1 Catalog Na. 04- 53480041 -01 1a Printed In U.S.A. :Form 48/60A-6T f'g CI: Raglan= 12.07 Raglan= New Tab = tb ' w z 7 0 0 0 w z 0 0 U ENGINEER: MM -- C. LEE MacDonald - Miller FACILITY SOLUTIONS NEBB CERTIFIED - TEST, ADJUST & BALANCE REPORT FOR GATEWAY BUILDING 7 738- 6215 -00 12720 GATEWAY DRIVE S TUKWILLA WA 98168 THE DATA PRESENTED IN THIS REPORT IS AN EXACT RECORD OF SYSTEM PERFORMANCE AND WAS OBTAINED IN ACCORDANCE WITH NEBB STANDARD PROCEDURES. ANY VARIANCES FROM DESIGN QUANTITIES, WHICH EXCEED NEBB TOLERANCES, ARE NOTED THROUGHOUT THIS REPORT. THE AIR DISTRIBUTION SYSTEMS HAVE BEEN TESTED & BALANCED AND FINAL ADJUSTMENTS HAVE BEEN MADE IN ACCORDANCE WITH. NEBB "PROCEDURAL STANDARDS FOR TESTING, ADJUSTING & BALANCING OF ENVIRONMENTAL SYSTEMS" AND.THE PROJECT SPECIFICATIONS. SUBMITTED & CERTIFIED BY: BRIAN WHEELER DATE: AUGUST 15, 2008 Certification Expiration Date: MARCH 31, 2010 FIELD FOREMAN: RON LANDBERG MACDONALD- MILLER FACILITY SOL UTIONS MECHANICA'LSERVICES 02661 . 7717 DETROIT AV.ENUF SW . SEATTLE. WASHINGTON 9.$106 PHONE: (206) 763 -9400 FAX: (2o6i :767 -6773 MacDonald - Miller '= FACILITY SOLUTIONS GA TE{W!4Y 7 B UILDING P!LlSE 2 JOB # 738 - 6215 - 00 2) Scope of work a) Test and Balance of the new air distribution systems with in the TI area. b) Documentation of any deficiencies and to provide a certified balance report. 3) Description of the System a) Total of 41 Siemens pinch type VAV boxes installed through out the building. b) One Nailor parallel VAV box with factory installed heat strips. c) Four existing stand alone Rheetn fan coil units.. d) Stacfa Talon Controls system. c) Wall mounted Staefa Talon sensors with communication jacks. 1) Staefa Talon programmable thermostats installedto control fan coil wins. g) Sheet metal air distribution system with installed volume dampers. TAB` REPORT SUMNfARY 1) General Notes a) 1 -IVAC balancing was completed 8 -15 -2008. b) •TAB work was in accordance with NEBB procedural standards. c) Design information was obtained from mechanical drawings, submittals, specifications, or shop drawings as available. 4) TAB Procedures Summarized a) Outlet volumetric flow rates were measured by use of a calibrated digital Flow Hood. h) All VAV's were calibrated at the maximum flow position, and multipliers noted on the balance report. c) All VAV's were zeroed by controls technician, values of offsets were noted on the balance report. d) Wall sensors were calibrated to insure consistent readings throughout the building., . e) Grill deflections were adjusted to insure proper flow direction. 5) Other miscellaneous notes a) full load test results of the RTU -2, show that the unit is only delivering 85% of intended flow. RTU -2 has enough capacity to be sped_ up by 5 %, or by 1 1 N CFM. • b) Unable to attain full flow on three zones on first floor with current static set points. Air balance was done during the night, at which the air handler is running at the lowest static set point because of lack of cooling, load. c) See Field Inspection Report for all deficiencies and recommendations. Project Manager: Steven Flink / Dan Freyling Field Technician: Oleg Stepanyuk (Test and Balance) Pg. 1 r Corridor Design 1 CD 8 "0 Hood Vel. 1 Flow 130 Vel. l , Flow 105 115 88% Resource Center 103% 2 CD 8 "0 Hood 8 "0 330 170 285 86% Resource Center 0 3 CD 8 "0 Hood . 330 195 270 82% Staff Lounge 96% 4 ' CD 8 "0 Hood 8 "0 170 310 150 88% Staff Lounge T 5 CD 8 "0 • Hood . . 170 110 245 275 145 85% Outlet Design Preliminary Final Percent of Design No. l Type 1 Size 1 Ak Vel. 1 Flow Vel. 1 Flow Vel. l , Flow VVT -102 I - Classroom T 1 CD 8 "0 Hood 150 210 155 103% Classroom T 2 CD 8 "0 Hood. 150 220 155 103% C!assroorn 3 CD 8 "0 Hood . 280 160 . .270. 96% Classroom 0 4 CD 8 "0 Hood 280 165 .. 280 100% I VVT -103 - Resource Center 1 CD 8 "0 Hood 240 230 245 102% Resource Center T 2 ' CD 8 "0 Hood 240 245 235 98% Resource Center 3 CD 8 "0 Hood 240 275 . 240 100% Mens Bathroom 4 CD 8 "0 Hood 110 245 .. 105 95% Womens Bathroom 5 CD 8 "0 Hood 110 275 115 105% Project Job Number Area Served VVT -101 Address Inlet Size Multiplier Offset Address Inlet Size Multiplier Offset Remarks: Address ... Inlet Size Multiplier Offset Mac®.onald- Miller FACILITY SOLUTIONS Totals Totals Totals Gateway Bldg 7 Phase 2 738 - 6215 -00 101 Max SP 1129 12 "0 Min SP 280 61% 0.55% Remarks: Unable to attain. design flow with current SP set point. 102 Max SP 860 12 "0 Min SP 339 74% 1.62% 103 Max SP 941 12 "0 Min SP' 280 60% 1.33% Remarks: Exhaust Womens 190 CFM 1 Mens 160 CFM System 1130 860 940 Max Flow Min Flow Max Flow Min Flow Max Flow Min Flow 1025 755 Design 795 New & Existing Design Actual 1130 280 Design Air Outlet Test Report 965 85% Actual 965 273 . 860 100% 860 340 860 331 940 100% Actual 940 940 280 273 .Test Date 8/15/200.8. • Readings By OVS - Page: 2 Lab 2 . 0 1 CD • 8 "0 Hood Preliminary I Final ,' 230 No. ( 165 l Size 235 102% Lab .2 . • Vel. 1 Flow j Vel. ' l Flow 2 CD 8 "0 Hood 230' . 245 220 96% Lab.2 3 CD 8 "0 Hood 230 295 215 93% Lab 2 T 4 CD 8 "0 Hood 230 185 220 96% Corridor 5 CD 8 "0 Hood ' 100 205 100 100% Lab 2 T 1 CD 8 "0 Hood Preliminary I Final ,' 230 No. ( 270 l Size 215 93% Lab 2 Vel. 1 Flow j Vel. ' l Flow 2 CD 8 "0 Hood 230 270 . 230 100% Lab 2 . 3 CD 8 "0 Hood 230 165 235.. 102% Lab 2 0 4 CD 8 "0 Hood 230 .235 220 96% Project Job Number. L Area Served VVT -123 Address Inlet Size Multiplier Offset Remarks: -124 Address Inlet Size Multiplier Offset Remarks: MacDonald - Miller FACILITY SOLUTIONS Totals Totals Gateway'BIdg 7 Pha 2 738- 6215 -00 123 Max SP 1019 • 10 "0 Min SP 320 77% 0.56% 124 Max SP 920 10 "0 Min SP 309 75% - .62% System 1020 920 Max Flow Min Flow 1095 Air Outlet Test Report New & Existing . Design 990 97% Actual 1020 320 990 322 940 900 Design Max Flowl 920 Min Flow 310 Actual 98% 900 299 Test Date 8/15/2008 Readings By OVS Page: 3 Outlet Design Preliminary I Final ,' Percent or Design No. ( Type l Size l Ak Vel. ] Flow Vel. 1 Flow j Vel. ' l Flow Project Job Number. L Area Served VVT -123 Address Inlet Size Multiplier Offset Remarks: -124 Address Inlet Size Multiplier Offset Remarks: MacDonald - Miller FACILITY SOLUTIONS Totals Totals Gateway'BIdg 7 Pha 2 738- 6215 -00 123 Max SP 1019 • 10 "0 Min SP 320 77% 0.56% 124 Max SP 920 10 "0 Min SP 309 75% - .62% System 1020 920 Max Flow Min Flow 1095 Air Outlet Test Report New & Existing . Design 990 97% Actual 1020 320 990 322 940 900 Design Max Flowl 920 Min Flow 310 Actual 98% 900 299 Test Date 8/15/2008 Readings By OVS Page: 3 Office 0 1 CD 8 "0 Hood Vel. 1 Flow 220 Vel. 1 Flow 210 235 107% Office T 2 CD 8 "0 Hood 12 "0 220 285 215 98% Conference Rm 94% 3 CD 8 "0 Hood 12 "0 310 310 315 102% Corner Office 74% 4 CD 12 "0 Hood 540 830 510 94% Lab #1 , T 1 CD 8 "0... , Hood Vel. 1 Flow 190 Vel. 1 Flow 265 .200 105% Lab #1 O 2 CD 8 "0 Hood 12 "0 190 250 195 103% Lab #1 94% 3 CD 8 "0 Hood 12 "0 190 285 190 100% Lab #1 74% 4 CD 8 "0 Hood 190 255 200 105% Outlet Design Preliminary Final Percent of Design No.1 Type 1 Size 1 Ak Vel. 1 Flow Vel. 1 Flow Vel. 1 Flow VVT -126 1 Lobby 1 CD 12 "0 Hood 470 480 560 119% Lobby T 2 CD 12 "0 Hood 470 325 440 94% Conference A 3 CD 12 "0 Hood 360 230 265 74% Project Job Number Area Served Address Inlet Size Multiplier Offset VVT -125 Remarks: Address Inlet Size Multiplier Offset WT -127 Address Inlet Size Multiplier Offset MacDonald - Miller FACILITY SOLUTIONS Totals Totals Totals Gateway Bldg 7 Phase 2 738 - 6215 -00 System New & Existing Air Outlet Test Report 125 Max SP 759 10 "0 Min SP 320 76% - .75% 126 Max SP 1299 12 "0 Min SP 328 61% . - 57% Remarks: No access to volume dampers( hard lid ceiling ). Unable to proportion the outlets. 127 Max SP 1288 12 "0 Min SP 328 73% 0.55% 760 1300 1290 Remarks: Thermostat might need to be moved to Corner Office Instead of interior wall. Max Flow Min Flow Max Flow Min Flow Max Flow Min Flow 1055 Design 785 103% Actual 760 320 785 320 1035 1635 Design Design 1265 97% Actual 1300 330 1265 333 1275 99% Actual 1290 330 1275 333 Test Date 8/15/2008 Readings By OVS Page: 4 Office 1 0 1 CD 10 "0 Hood Vel. 1 Flow 280 Vel. 1 Flow 155 270 96% Office T 2 CD 10 "0 Hood 300 315 295 98% Office 3 CD 10 "0 Hood 270 325 255 94% Office 4 CD 10 "0 Hood 220 295 205 93% Outlet Design Preliminary Final Percent of Design No. 1 Type 1 Size 1 Ak Vel. 1 Flow Vel. 1 Flow Vel. 1 Flow Project Job Number Area Served VVT -128 VVT -129 1 Address Inlet Size Multiplier Offset Remarks: Address 129 Max SP 379 Inlet Size 8 "0 Min SP 148 Multiplier 64% Offset -. 18% Remarks: Remarks: VVT -130 Address Inlet Size Multiplier Offset MacDonald - Miller FACILITY SOLUTIONS Totals Totals Test Date 8/15/2008 Gateway Bldg 7 Phase 2 738 - 6215 -00 System New & Existing Air Outlet Test Report Corner Office 1 T 1 1 1 CD 1 12 "0 ( Hood 1 1 490 1 1 610 1 1 490 1 100% I 490 100% 128 Max SP 489 8 "0 Min SP 148 73% -.16% No access to the office. VAV was set and balanced using Nailor flow chart. Dir. of Rectruitmen( T 1 1 1 CD 1 12 "0 1 Hood 1 Totals 130 Max SP 1068 10 "0 Min SP 210 96% 0.70% 490 1 380 1 1 360 1 380 1070 Max Flow Min Flow Max Flow Min Flow Max Flow Min Flow 610 Design 360 Design Actual 490 150 490 160 1 380 1 100% 1 380 100% Actual 380 150 380 153 1090 Design 1025 96% Actual 1070 210 1025 210 Readings By OVS Page: 5 Office r 1 CD 6 "0 Hood Vel. l Flow 70 Vel. 1 Flow 250 45 64% Student Loundge T/O 2 CD 8 "0 Hood 10 "0 410 235 265 .65% Student Loundge 97% 3 CD 8 "0 Hood 10 "0 410 300 265 65% Student Loundge 94% 4 CD 8 "0 Hood 8 "0 410 285 270 66% Outlet Design Preliminary Final Percent of Design No. l Type 1 Size 1 Ak Vel. l Flow Vel. l Flow Vel. 1 Flow VVT -133 Theory 0 1 CD 8 "0 Hood 310 220 295 95% Theory 2 CD 10 "0 Hood 310 320 300 97% Theory 3 CD 10 "0 Hood 310 445 290 94% Theory T 4 CD 8 "0 Hood 310 240 305 98% Project Job Number Area Served WT -131 Address Inlet Size Multiplier Offset Remarks: VVT -132 Office Address 132 Max SP 259 Inlet Size 8 "0 Min SP 148 Multiplier 69% Offset 0.09% Remarks: Address Inlet Size Multiplier Offset Remarks: MacDonald - Miller FACILITY SOLUTIONS Totals T 1 CD 8 "0 Hood Totals VAV installed too dose to the main duct. Totals Gateway Bldg 7 Phase 2 738 - 6215 -00 131 Max SP 1299 12 "0 Min SP 328 59% .25% 133 Max SP 1240 12 "0 Min SP 328 66% 0.18% System 1300 Outlet #1 is 100% closed. Unable to attain design flow with current SP set point. 260 260 1240 Max Flow Min Flow Max Flow Min Flow Max Flow Min Flow 1070 1300 330 845 335 265 265 260 150 260 155 1225 New & Existing Design Design Design Air Outlet Test Report 845 Actual 260 100% 260 100% Actual 1190 96% Actual 65% 1240 330 1190 333 Test Date 8/15/2008 Readings By OVS Page: 6 Lab T/0 1 CD 12 "0 ' Hood Vel. 1 Flow 510 Vel. 1 Flow 385 40 415 81% • Lab 113% 2 CD 12 "0 Hood 8 "0 510 Hood 405 250 405 79% Lab 106% 3 CD 12 "0 Hood 8 "0 510 Hood 435 170 425 83% Outlet Design Preliminary Final Percent of Design No. l Type 1 Size 1 Ak Vel. 1 Flow Vel. 1 Flow Vel. 1 Flow VVT -135 1 J Book Store Storage 1 CD 8 "0 Hood Hood 40 40 85 140 45 113% Office T/O 2 CD 8 "0 Hood Hood 80 250 100 210 85 106% Office Testing 3 CD 8 "0 Hood Hood 60 170 90 120 60 100% ( VVT -136 J Storage 0 1 CD 8 "0 Hood 40 140 45 113% Office 2 CD 8 "0 Hood 250 210 255 102% Testing T 3 CD 8 "0 Hood 170 120 165 97% Project Job Number Area Served VVT -134 Address Inlet Size Multiplier Offset Remarks: Unable to attain design flow with current SP set point. Address Inlet Size Multiplier Offset Remarks: Address Inlet Size Multiplier Offset Remarks: MacDonald - Miller FACILITY SOLUTIONS Totals Totals Totals Gateway Bldg 7 Phase 2 738- 6215 -00 134 Max SP 1290 12 "0 Min SP 80% 0.11% 135 Max SP 178 6 "0 Min SP 70 70% 0.25% 136 Max SP 460 8 "0 Min SP 148 67% -.28% System 1530 180 460 Max Flow Min Flow Max Flow Min Flow Max Flow Min Flow 1225 1530 330 1245 326 275 470 New & Existing Design Design Design Air Outlet Test Report 1245 81% Actual 190 106% Actual 180 70 190 72 465 101% Actual 460 150 465 155 Test Date 8/15/2008 Readings By OVS Page: 7 Storage Design 1 CD 8 "0 Hood Vel. 1 Flow 40 Vel. 1 Flow 0 45 113% Lab 3 0 2 CD 8 "0 Hood 8 "0 110 145 105 95% Lab 3 104% 3 CD 8 "0 Hood 8 "0 110 150 110 100% Lab 3 100% 4 CD 8 "0 Hood 8 "0 110 220 115 105% Lab 3 T 5 CD 8 "0 Hood 110 190 110 100% Outlet Design Preliminary Final Percent of Design No. 1 Type 1 Size 1 Ak Vel. 1 Flow Vel. 1 Flow Vel. 1 Flow VVT -137 1 Conference C 0 1 CD 8 "0 Hood 70 95 65 93% Copy Room T 2 CD 8 "0 Hood 120 120 125 104% Copy Room 0 3 CD 8 "0 Hood 120 75 120 100% Conference B 4 CD 8 "0 Hood 100 75 120 120% VVT -139 1 Open Office 0 1 CD 10 "0 Hood 260 200 265 102% Open Office 2 CD 12 "0 Hood 430 420 415 97% Open Office T 3 CD 12 "0 Hood 400 295 385 96% Corridor 4 CD 10 "0 Hood 130 430 120 92% Project Job Number Area Served Address Inlet Size Multiplier Offset VVT -138 Address Inlet Size Multiplier Offset Remarks: MacDonald - Miller FACILITY SOLUTIONS Totals Totals Gateway Bldg 7 Phase 2 738 - 6215 -00 137 Max SP 409 8 "0 Min SP 178 69% 0.09% Remarks: #4 is 100% closed. 138 Max SP 479 10 "0 Min SP 328 77% 0.36% Address Inlet Size Multiplier Offset Remarks: Totals 139 Max SP 1220 12 "0 Min SP 331 75% 0.38% System 410 480 1220 Max Flow Min Flow Max Flow Min Flow Max Flow Min Flow 365 705 1345 New & Existing Design Design Air Outlet Test Report 430 105% Actual 410 180 430 182 485 101% Design Actual 480 330 485 322 1185 97% Actual 1220 330 1185 337 Test Date 8/15/2008 Readings By OVS Page: 8 Open Space T 1 CD 8 "0 Hood Percent of Des 125 1 155 Vel. 1 Flow 125 100% Open Space T/O 2 CD 8 "0 Hood 8 "0 200 160 200 100% Mens Bathroom 0 1 CD 8 "0 Hood 8 "0 100 80 100 100% Womens Bath. 83% 2 CD 8 "0 Hood 100 135 105 105% Theory #7 T 1 LD 10 "0 Hood Percent of Des 260 1 325 Vel. 1 Flow 260 100% Theory #7 107% 2 LD 10 "0 Hood 8 "0 260 320 260 100% Theory #7 0 3 LD 10 "0 Hood 8 "0 260 265 265 102% Theory #7 83% 4 LD 10 "0 Hood 260 285 280 108% Outlet Lobby Design Preliminary Final Percent of Des No. 1 Type l Size 1 Ak Vel. 1 Flow Vel. 1 Flow Vel. 1 Flow VVT -222 1 Lobby T 1 LD 8 "0 Hood 300 390 320 107% Lobby 2 LD 8 "0 Hood 300 390 330 110% Lobby 3 LD 8 "0 Hood 300 340 250 83% Project Job Number Area Served VVT -201 Address Inlet Size Multiplier Offset Remarks: Address Inlet Size Multiplier Offset Remarks: Address Inlet Size Multiplier Offset Remarks: VVT -223 MacDonald - Miller FACILITY SOLUTIONS Totals Totals Totals Gateway Bldg 7 Phase 2 738 - 6215 -00 201 Max SP 525 12 "0 Min SP 125 60% 1.97% 222 Max SP 898 12 "0 Min SP 328 94% -.61% 223 Max SP 1038 12 "0 Min SP 328 77% 0.10% System 525 900 1040 Max Flow Min Flow Max Flow Min Flow Unable to proportion the outlets. Balancing dampers are located above the hard lid ceiling. VVT set for total. Max Flow Min Flow 530 New & Existing Design Air Outlet Test Report 530 101% Actual 525 125 530 127 1120 1195 Design 900 330 900 326 Design 900 100% Actual 1065 102% Actual 1040 330 1065 324 Test Date 8/15/2008 Readings By OVS Page: 9 , Storage , 1 LD 8 "0 Hood Final 90 No. l 0 [ 90 100% Storage Vel. l Flow 2 LD 8 "0 Hood 90 185 85 94% Open Space 0 3 LD 8 "0 Hood 310 235 305 98% Open Space T 4 LD 8 "0 Hood 310 250 325 105% Lab #5 T/O 1 LD 10 "0 Hood Final 290 No. l 250 [ 280 97% Lab #5 Vel. l Flow 2 LD 10 "0 Hood 290 295 280 97% Lab #5 3 LD 10 "0 Hood 290 310 285 98% Lab #5 4 LD 10 "0 Hood 290 290 295 102% Lab #7 Outlet 1 LD Design Preliminary Final Percent of Design No. l Type ] Size [ Ak Vel. l Flow Vel. l Flow Vel. l Flow Lab #7 T/O 1 LD 10 "0 Hood 280 275 265 95% Lab #7 2 LD 10 "0 Hood 280 325 285 102% Lab #7 3 LD 10 "0 Hood 280 355 275 98% Lab #7 4 LD 10 "0 Hood 280 285 290 104% Project Job Number Area Served VVT -224 Address Inlet Size Multiplier Offset Remarks: VVT -225 Address Inlet Size Multiplier Offset Remarks: VVT -226 Address Inlet Size Multiplier Offset MacDonald - Miller FACILITY SOLUTIONS Totals Totals Totals Gateway Bldg 7 Phase 2 738 - 6215 -00 224 Max SP 1119 12 "0 Min SP 328 87% 0.59% 225 Max SP 1159 12 "0 Min SP 328 60% 0.67% 225 Max SP 799 10 "0 Min SP 210 63% System 1120 1160 800 Remarks: Thermostat location is not ideal, because its too close to coffee brewing station which generates heat. Max Flow Min Flow Max Flow Min Flow Max Flow Min Flow 1240 1120 330 1115 335 1145 1160 330 1140 328 670 New & Existing Design Design Design Air Outlet Test Report 1115 100% Actual 1140 98% Actual 805 101% Actual 800 210 805 212 Test Date 8/15/2008 Readings By OVS Page: 10 Instructors T/O 1 LD 8 "0 Hood Vel. l Flow 260 Vel. 1 Flow 185 260 100% Instructors 2 LD 8 "0 Hood 260 255 255 98% Instructors 3 LD 8 "0 Hood 260 195 260 100% Instructors T 4 LD 8 "0 Hood 260 230 260 100% Outlet Design Preliminary Final Percent of Design No.I Type 1 Size 1 Ak Vel. l Flow Vel. 1 Flow Vel. 1 Flow Instructors , 1 LD 8 "0 Hood 260 260 260 100% Instructors 2 LD 8 "0 Hood 260 265 265 102% Instructors 3 LD 8 "0 Hood 260 260 260 100% Instructors T 4 LD 8 "0 Hood 260 265 265 102% Project Job Number Area Served Address Inlet Size Multiplier Offset VVT -227 Remarks: WT -228 MacDonald - Miller FACILITY SOLUTIONS Totals Gateway Bldg 7 Phase 2 738 - 6215 -00 227 Max SP 1038 12 "0 Min SP 328 72% 0.44% System 1040 Max Flow Min Flow VVT was calibrated and set for total. Not able to read outlets due to furniture and obstructions. No drafts or velocity noise was noticed during the balance. 1050 New & Existing Design Air Outlet Test Report 1050 101% Actual 1040 330 1050 328 Address Inlet Size Multiplier Offset Remarks: Totals 228 Max SP 1038 12 "0 Min SP 328 69% 0.21% 1040 Max Flow Min Flow 865 Design 1035 100% Actual 1040 330 1035 331 Test Date 8/15/2008 Readings By OVS Page: 11 Theory #3 I T/0 1 LD 9 "0 Hood Vel. 1 Flow 270 Vel. 1 Flow 200 275 102% Theory #3 2 LD 9 "0 Hood 270 235 275 102% Theory #3 3 LD 9 "0 Hood 270 200 270 100% Outlet Design Preliminary Final Percent of Design No. 1 Type 1 Size 1 Ak Vel. 1 Flow Vel. 1 Flow Vel. 1 Flow Theory #3 T 1 LD 9 "0 Hood 230 375 220 96% Theory #3 2 LD 9 "0 Hood 230 280 225 98% Theory #3 3 LD 9 "0 Hood 230 310 245 107% Theory #3 4 LD 9 "0 Hood 230 205 245 107% Theory #3 0 5 LD 9 "0 Hood 230 170 235 102% Theory #3 6 LD 9 "0 Hood 70 220 75 107% Area Served Project Job Number Address Inlet Size Multiplier Offset Remarks: VVT -230 Address Inlet Size Multiplier Offset Remarks: VVT -229 MacDonald - Miller FACILITY SOLUTIONS Totals Totals Gateway Bldg 7 Phase 2 738 - 6215 -00 229 Max SP 810 14 "0 Min SP 400 66% 1.02% 230 Max SP 1220 16 "0 Min SP 629 75% 0.81% System 810 1220 Max Flow Min Flow Max Flow Min Flow 635 1560 Existing AHU -3 Design Design Air Outlet Test Report 820 101% Actual 810 400 820 395 1245 102% Actual 1220 630 1245 629 Test Date 8/15/2008 Readings By OVS Page: 12 Lab #8 T 1 LD 9 "0 Hood Vel. 1 Flow 330 Vel. 1 Flow 330 335 330 100% Lab #8 LD 2 LD 9 "0 Hood 330 320 97% 320 97% Lab #8 9 "0 3 LD 9 "0 Hood 365 330 330 320 Lab #6 320 97% Lab #8 Hood 4 LD 9 "0 Hood 330 102% 310 5 310 94% Lab #8 0 5 LD 9 "0 Hood 335 330 305 305 92% Outlet Design Preliminary Final Percent of Design No. 1 Type 1 Size 1 Ak Vel. 1 Flow Vel. 1 Flow Vel. 1 Flow Lab #6 T 1 LD 9 "0 Hood 330 375 335 102% Lab #6 2 LD 9 "0 Hood 330 400 320 97% Lab #6 3 LD 9 "0 Hood 330 365 330 100% Lab #6 4 LD 9 "0 Hood 330 410 335 102% Lab #6 0 5 LD 9 "0 Hood 330 350 335 102% Project Job Number Area Served VVT -231 Address Inlet Size Multiplier Offset Remarks: VVT -232 Address Inlet Size Multiplier Offset Remarks: MacDonald - Miller FACILITY SOLUTIONS Totals Totals Gateway Bldg 7 Phase 2 738 - 6215 -00 System 231 Max SP 1651 16 "0 Min SP 629 80% - .79% 232 Max SP 1651 16 "0 Min SP 629 61% 0.66% 1650 Origional outlet design was for 400 CFM. Supply LD's get very noisy much higher than 330 CFM. In order to achieve original box total of 2000, additional outlets need to be added in order to satisfy load demand. 1650 Max Flow Min Flow Max Flow Min Flow 1900 1585 Existing AHU -3 Design Design Air Outlet Test Report 1655 100% Actual 1650 630 1655 610 1585 96% Actual 1650 630 1585 627 Origional outlet design was for 540 CFM. Supply LD's get very noisy much higher than 330 CFM. In order to achieve original box total of 2160, additional outlets need to be added in order to satisfy load demand. Test Date 8/15/2008 Readings By OVS Page: 13 Outlet Design Preliminary Final Percent of Des'gn No.l Type 1 Size l Ak Vel. l Flow Vel. 1 Flow Vel. 1 Flow Theory 4 1 CD 8 "0 Hood 8 "0 210 220 220 105% Theory 4 T 2 LD 8 "0 Hood 8 "0 210 300 205 98% Theory 4 97% 3 LD 8 "0 Hood 8 "0 210 255 200 95% Theory 4 0 4 LD 8 "0 Hood 210 245 210 100% VVT -234 1 Theory 5 T 1 CD 8 "0 Hood 180 190 190 106% Theory 5 0 2 LD 8 "0 Hood 180 135 175 97% Theory 5 T 3 LD 8 "0 Hood 180 195 _ 180 100% VVT -235 RREEF Office T 1 CD 8 "0 Hood 270 275 270 100% Theory #6 0 2 LD 8 "0 Hood 360 345 360 100% Deans Office 3 CD 8 "0 Hood 260 345 275 106% Project Job Number Area Served VVT -233 Address Inlet Size Multiplier Offset Remarks: Address Inlet Size Multiplier Offset Remarks: Address Inlet Size Multiplier Offset MacDonald - Miller FACILITY SOLUTIONS Totals Totals Totals Gateway Bldg 7 Phase 2 738 - 6215 -00 233 Max SP 839 12 "0 Min SP 328 82% -.18% 234 Max SP 538 8 "0 Min SP 210 71% 0.04% 235 Max SP 890 12 "0 Min SP 328 78% 2.42% Remarks: VAV is hunting in order to achieve design airflow. System 840 540 890 Max Flow Min Flow Max Flow Min Flow Max Flow Min Flow 1020 840 340 835 322 520 540 210 545 210 965 New & Existing Design Design Design Air Outlet Test Report 835 99% Actual 545 101% Actual 905 102% Actual 890 330 905 328 Test Date 8/15/2008 Readings By OVS Page: 14 Cubicals T/O 1 CD 8 "0 Hood Preliminary 170 Percent of Design 310 Type l Size 175 103% Cubicals 2 CD 8 "0 Hood 8 "0 170 8 "0 45 180 106% 910 Outlet 210 212 Design Preliminary Final Percent of Design No. l Type l Size l Ak Vel. 1 Flow Vel. 1 Flow Vel. 1 Flow 910 890 210 212 760 760 Office 0 1 CD 8 "0 Hood 8 "0 370 220 360 97% Office T 2 CD 8 "0 Hood 8 "0 210 245 200 95% Office 100% 3 CD 8 "0 Hood 8 "0 200 210 205 103% Office 104% 4 CD 8 "0 Hood 130 205 125 96% ( VVT -237 Reception T 1 CD 8 "0 Hood 210 260 210 100% Lunch Room 2 CD 8 "0 Hood 180 295 180 100% Copy Room O 3 CD 8 "0 Hood 240 250 250 104% Project Job Number Area Served VVT -236 Address Inlet Size Multiplier Offset Address Inlet Size Multiplier Offset Remarks: VVT -238 Address Inlet Size Multiplier Offset Remarks: MacDonald - Miller FACILITY SOLUTIONS Totals Totals Totals Gateway Bldg 7 Phase 2 738 - 6215 -00 236 Max SP 909 10 "0 Min SP 210 67% Filter 16x25x1 1.49% Remarks: Box marked VAV -202 on the print 237 Max SP 629 8 "0 Min SP 148 66% 0.04% 238 Max SP 339 8 "0 Min SP 148 76% 0.17% System 910 630 340 Max Flow Min Flow Fan Flow Max Flow Min Flow Max Flow Min Flow 880 805 355 New & Existing Design Design Design Air Outlet Test Report 890 98% Actual 640 102% Actual 630 150 640 148 355 104% Actual 340 150 355 155 Test Date 8/15/2008 Readings By OVS Page: 15 Corridor T 1 CD 7 "0 Hood Vel. 1 Flow 100 Vel. 1 Flow 300 100 100 100% Corridor 0 2 CD 8 "0 Hood 200 240 100% 200 100% Outlet Design Preliminary Final Percent of Design No.) Type 1 Size j Ak Vel. 1 Flow Vel. 1 Flow Vel. 1 Flow Mans Bathroom j 1 CD 6 "0 Hood 100 115 100 100% Womens Bathroom 2 CD 6 "0 Hood 100 115 100 100% Office 3 CD 8 "0 Hood 90 245 95 106% Office 4 CD 8 "0 Hood 90 235 100 111% Theory #6 5 LD 10 "0 Hood 360 295 355 99% Theory #6 6 LD 10 "0 Hood 360 280 340 94% Theory #6 T/O 7 LD 10 "0 Hood . 360 265 .325 90% Project Job Number Area Served VVT -239 Address Inlet Size Multiplier Offset Remarks: VVT -240 Address Inlet Size Multiplier Offset Remarks: MacDonald - Miller FACILITY SOLUTIONS Totals Totals Gateway Bldg 7 Phase 2 738- 6215 -00 System 239 Max SP 1460 12 "0 Min SP 379 82% 0.22% 1460 239 Max SP 299 8 "0 Min SP 148 72% - .42% 300 Max Flow Min Flow Max Flow Min Flow 1550 540 New & Existing Design Design Air Outlet Test Report 1415 97% Actual 1460 380 1415 381 300 100% Actual 300 150 300 153 Test Date 8/15/2008 Readings By OVS Page: 16 Career Services T/O 1 CD 8 "0 Hood Vel. 1 Flow 240 Vel. 1 Flow 290 225 94% Corridor 97% 2 CD 8 "0 Hood 8 "0 100 240 100 100% Storage 103% 3 CD 8 "0 Hood 8 "0 60 305 60 100% Storage 94% 4 CD 8 "0 Hood 60 0 90 150% Server 5 CD 6 "0 Hood 100 0 80 80% Outlet Design Preliminary Final Percent of Design No.l Type 1 Size 1 Ak Vel. 1 Flow Vel. 1 Flow Vel. 1 Flow VVT -243 Conference Room 0 1 CD 8 "0 Hood 160 175 155 97% Conference Room 2 CD 8 "0 Hood 180 220 185 103% Conference Room T 3 CD 8 "0 Hood 180 210 170 94% Project Job Number Area Served Address Inlet Size Multiplier Offset VVT -241 Remarks: Address Inlet Size Multiplier Offset Remarks: MacDonald - Miller FACILITY SOLUTIONS Totals Totals Gateway Bldg 7 Phase 2 738 - 6215 -00 241 Max SP 559 8 "0 Min SP 148 72% 0.24% 243 Max SP 519 8 "0 Min SP 259 73% 0.69% System 560 520 Max Flow Min Flow Outlets 4 & 5 share a Y connection. No dampers available to balance. Max Flow Min Flow 835 605 New & Existing Design Design Air Outlet Test Report 555 99% Actual 560 150 555 155 510 98% Actual 520 260 510 263 Test Date 8/15/2008 Readings By OVS Page: 17 Lab 2 . T /O 1 CD 12 "0 Hood 600 600 380 345 475 480 80% Lab 2 CD 2 CD 12"0 Hood 600 440 80% 460 77% Lab 1 �T /O 1 CD 12 "0 Hood Hood 600 600 380 440 475 79% Lab 1 I 2 CD 12 "0 Hood 12 "0 600 405 480 80% Lab 2 1170 1 CD 12 "0 Hood Hood 600 600 335 440 455 76% Lab 2 2 CD 12 "0 Hood 12 "0 600 565 430 72% Lab 3 T 1 CD 12 "0 Hood Vel. 1 Flow 600 Vel. l Flow 440 355 59% Lab 3 0 2 CD 12 "0 Hood 600 275 340 57% Outlet Design Preliminary Final Percent of Design No.l Type 1 Size 1 Ak Vel. 1 Flow Vel. l Flow Vel. l Flow Project Job Number Area Served FCU -101 MacDonald - Miller FACILITY SOLUTIONS Totals Gateway Bldg 7 Phase 2 738 - 6215 -00 Remarks: FCU is factory wired to run on Hi speed. FCU -102 FCU -103 Totals Remarks: Dirty filter. Readings taken without return filter. FCU is factory wired to run on Hi speed. Totals Remarks: FCU is factory wired to run on Hi speed. FCU -104 Totals Remarks: Dirty filter. Readings taken without return filter. FCU is factory wired to run on Hi speed. System 1200 1200 1200 715 785 900 1200 785 New & Existing Fan Coil Units found to be underperforming. This could be attributed to extensive length of fexible duct. Some runs are approximately 32 feet in length. Air Outlet Test Report 695 58% 940 78% 885 74% 955 80% Test Date 8/15/2008 Readings By OVS Page: 18 Manufacturer Carrier Model 48A3T060DSV611 HM Serial Number 2108U14034 Fan Type /Size FC Motor Manufacturer A.O. Smith Frame Y286T Motor Horsepower 30 F.L. Amps 36.6 Service Factor 1.15 Voltage 460 Phase 3 Power Factor 82% Nominal Efficiency 94% Fan Sheave Make 24000 Browning Fan Sheave Model 28400 3B5V94 Bushing /Bore Size 16800 B 1 15/16" Motor Sheave Make 7200 Browning Motor Sheave Model DNA 3B5V58 Bushing /Bore Size DNA B 1 7/8" Motor Adjustment +1 1 /2" / -2 1/2" Sheave Adjustment ( %) 1.2 Fixed Centerline Distance 1010 15" No. Belts /Belt Size 36.6 3 / 5VX550 No. of Filters/Type /Size 16 - 20x24x2 Total Capacity -Fan 24000 20392 Total Capacity - Outlets 28400 19324 Return Air Quantity 16800 14084 Outside Air Quantity 7200 6308 Suction Pressure DNA 1.793 Discharge Pressure DNA 0.667 Total Static Pressure DNA 2.46 External Static Pressure 1.2 1.57 Fan RPM 1010 1061 Motor RPM 1765 1765 Voltage T1 -T2 460 476 T2 -T3 473 T1 -T3 475 Amperage T -1 36.6 31.8 T -2 30.6 T -3 30.2 C.F.L.A. 36.6 35.4 BHP 26.1 Project Unit Service Unit Data Test Data MacDonald - Miller FACILITY SOLUTIONS Gateway Bldg 7 / Phase 2 Job Number 738- 6215 -00 RTU -2 Location Roof ITT Institute Design Actual Notes Design Outside air damper is set to 37% for minimum outside air requirement. Air System Test Report Actual Test Date 8/14/2008 Readings By OVS Page: 19 Depth 1 2 3 4 5 6 7 8 9 10 11 12 36 Average FPM 1 155 163 149 172 178 193 180 178 180 185 208 82 2 186 174 164 194 157 142 156 172 165 201 245 62 3 154 155 122 116 137 177 121 152 163 204 153 160 Subtotals 495 492 435 482 472 512 457 502 508 590 606 304 Test Data Required 1 Actual Width Height Duct Area 38.700 Static Pressure Atmos Total FPM 6698 I 5855 No. of Points 36 Average FPM 186 163 CFM 7200 6294 Project Location Altitude Density MacDonald - Miller FACILITY SOLUTIONS Gateway Bldg 7 / Phase 2 Roof Sea Level Standard Note: Readings are taken with air blowing toward the observer. 87% Test Date 8/14/2008 Readings By VeI •rid Job Number 738 - 6215 -00 System /Service RTU -2 Air Temperature 68 ° F Correction Factor 1.0 Remarks: 14.375x23.25/144`12 =27.85 18.25x23.25/144`6 =17.68 27.85 +17.68= 45.53`.85 =38.7 OVS OSA Traverse Page: 20 Depth 4" 10" 16" 22" 28" 34" 40" Static Pressure .489" Total FPM 78552 1 47900 No. of Points 42 Average FPM 2.5" 797 865 1062 997 1007 964 822 5.5" 1024 1145 1238 1276 1211 1104 1112 8.5" 1099 1262 1360 1383 1319 1221 1129 11.5" 1259 1422 1289 1312 1360 1297 1113 14.5" 1104 1350 1213 1277 1265 1219 1126 17.5" 727 1081 956 1111 1079 945 998 Subtotals 6010 7125 7118 7356 7241 6750 6300 Test Data Required I Actual Width 42 Height 18 Duct Area 5.250 Static Pressure .489" Total FPM 78552 1 47900 No. of Points 42 Average FPM 1870 1140 CFM 9819 5988 Project Location Altitude Density MacDonald - Miller FACILITY SOLUTIONS Gateway Bldg 7 / Phase 2 Above 1st Floor Bathrooms Sea Level Standard Note: Readings are taken with air blowing toward the observer. 61% Test Date 8/13/2008 Readings By 1► Airfoil Job Number System /Service Air Temperature Correction Factor Remarks: Actual duct size 44x20 Traverse taken with RTU -2 @ 100% and 25% OSA. OVS Rectangular Duct Traverse Report 738 - 6215 -00 RTU -2 / 1st Floor Branch B 70 °F 1.0 Page: 21 Test Data Required I Actual Diameter 26 Duct Area 3.687 Static Pressure .557" Total FPM 24280 1 20627 No. of Points 20 Average FPM 1214 1031 CFM 4476 3803 5/8" 2 1/8" 3 3/4" 5 7/8" 8 7/8" 339 737 1048 1238 1108 Project Location Altitude Density MacDonald - Miller FACILITY SOLUTIONS Gateway Bldg 7 / Phase 2 1st Floor Bathrooms Sea Level Standard Note: Readings are taken with air blowing toward the observer. 85% Test Date 8/13/2008 Readings By Pitot Tube Depth Vel. 5/8" 2 1/8" 3 3/4" 5 7/8" 8 7/8" 1238 1308 1319 1198 955 17 1/8" 20 1 /8" 22 1/4" 23 7/8" 25 3/8" 897 946 992 1113 1042 Round Duct Traverse Report Job Number 738 - 6215 -00 System /Service RTU -2 Air Temperature 70 °F Correction Factor 1.0 17 1/8" 945 20 1/8" 1028 22 1/4" 1051 23 7/8" 1134 25 3/8" 991 Remarks: Traverse taken with RTU -2 @ 100% and 25% OSA. .495" SP with RTU -2 @ 100% OSA OVS Page: 22 Depth 4" 10" 16" 22" 28" 34" 40" Static Pressure .576" Total FPM 1 48652 No. of Points 42 Average FPM 2.5" 979 1065 1062 955 1046 1060 1046 5.5" 1340 1424 1414 1415 1431 1435 1344 8.5" 1467 1460 1292 1181 1273 1510 1453 11.5" 1479 1243 1094 907 1146 1161 1461 14.5" 1317 1057 792 779 856 1206 1272 17.5" 999 1057 798 597 741 908 1130 Subtotals 7581 7306 6452 5834 6493 7280 7706 Test Data Required I Actual Width 42 Height 18 Duct Area 5.250 Static Pressure .576" Total FPM 1 48652 No. of Points 42 Average FPM 1429 1158 CFM 7500 6082 Project Location Altitude Density MacDonald - Miller FACILITY SOLUTIONS Gateway Bldg 7 / Phase 2 Above 2st Floor Bathrooms Sea Level Standard Note: Readings are taken with air blowing toward the observer. 81% Test Date 8/13/2008 Readings By 11 Airfoil Job Number System /Service Air Temperature Correction Factor Rectangular Duct Traverse Report 738 - 6215 -00 RTU -2 / 2nd Floor Branch B 70 °F 1.0 Remarks: Actual duct size 44x20 Traverse taken with RTU -2 @ 100% and 25% OSA. .524" SP with RTU -2 @ 100% OSA OVS Page: 23 Test Data Required 1 Actual Diameter 26 Duct Area 3.687 Static Pressure .667' Total FPM 26976 1 24514 No. of Points 20 Average FPM 1349 1226 CFM 4973 4519 5/8" 2 1/8" 3 3/4" 5 7/8" 8 7/8" 1293 1466 1401 1250 1178 Project Location Altitude Density MacDonald - Miller FACILITY SOLUTIONS Gateway Bldg 7 / Phase 2 2nd Floor Closet Sea Level Standard Note: Readings are taken with air blowing toward the observer. 91% Test Date 8/13/2008 Readings By Pitot Tube Depth Vel. 5/8" 2 1/8" 3 3/4" 5 7/8" 8 7/8" 1463 1402 1378 1289 1246 17 1/8" 20 1/8" 22 1/4" 23 7/8" 25 3/8" 1089 1130 1213 1320 1090 Round Duct Traverse Report Job Number 738 - 6215 -00 System /Service RTU -2 Air Temperature 70 °F Correction Factor 1.0 17 1/8" 1175 20 1/8" 1082 22 1/4" 1084 23 7/8" 1027 25 3/8" 938 Remarks: Traverse taken with RTU -2 @ 100% and 25% OSA. .582" SP with RTU -2 @ 100% OSA OVS Page: 24 Project: Gateway 7 Phase II Report Date 8/13/2008 Time Flow and Temp Balancing Report with Snapshot Data 1:03:44 1st Floor Branch Al Folder N Sub -Foie Box ID Zone Nam. Balanced F Snapshot [ Snapshot 1 Controller 1 Occ State Flow Setpt Flow (CFM Damper Pos ( %) 1 101 123 Yes 8/13/2008 1:01:43 COOLING OCCUPIE[ 1019 748 100 2 124 124 Yes 8/13/2008 1:01:47 COOLING OCCUPIE[ 920 665 100 3 125 125 Yes 8/13/2008 1:01:52 COOLING OCCUPIE[ 759 767 80 4 126 126 Yes 8/13/2008 1:01:56 COOLING OCCUPIE[ 1299 977 100 5 115 138 Yes 8/13/2008 1:02:02 COOLING OCCUPIE[ 479 473 47 4476 3630 Traverse Total 3803 Duct Leakage 5% Project: Gateway 7 Phase II Report Date 8/13/2008 Time 0:20:55 Flow and Temp Balancing Report with Snapshot Data 1st Floor Branch B i Folder N Sub -Fok Box ID Zone Nami Balanced F Snapshot [ Snapshot 1 Controller I Occ State Flow Setpt Flow (CFM Damper Pos ( %) 1 127 127 Yes 8/13/2008 0:18:29 COOLING OCCUPIE[ 1288 756 100 2 105A 128 Yes 8/13/2008 0:18:36 COOLING OCCUPIE[ 489 462 100 3 129 129 Yes 8/13/2008 0:18:42 COOLING OCCUPIE[ 379 295 100 4 107 130 Yes 8/13/2008 0:18:46 COOLING OCCUPIE[ 1068 426 100 5 108 131 Yes 8/13/2008 0:18:50 COOLING OCCUPIE[ 1299 500 100 6 109 132 Yes 8/13/2008 0:18:55 COOLING OCCUPIE( 259 250 98 7 110 133 Yes 8/13/2008 0:19:08 COOLING OCCUPIE[ 1240 733 100 8 111 134 Yes 8/13/2008 0:19:16 COOLING OCCUPIE[ 1530 691 100 9 135 135 Yes 8/13/2008 0:19:20 COOLING OCCUPIE[ 178 180 55 10 136 136 Yes 8/13/2008 0:19:24 COOLING OCCUPIE[ 460 227 100 11 137 137 Yes 8/13/2008 0:19:29 COOLING OCCUPIE[ 409 322 100 12 139 139 Yes 8/13/2008 0:19:33 COOLING OCCUPIE[ 1220 576 100 9819 5418 Traverse Total 5988 Duct Leakage 10% Project: Gateway 7 Phase II Report Date 8/13/2008 Time 1:35:57 Flow and Temp Balancing Report with Snapshot Data 2nd Floor Brandt A Folder .N Sub -Fok Box ID Zone Nam( Balanced F Snapshot [ Snapshot 1 Controller I Occ State Flow Setpt Flow (CFM Damper Pos ( %) 1 223 223 Yes 8/13/2008 1:34:44 COOLING OCCUPIE[ 1038 901 100 2 224 224 Yes 8/13/2008 1:34:47 COOLING OCCUPIE[ 1119 998 100 3 225 225 Yes 8/13/2008 1:34:51 COOLING OCCUPIE[ 1159 890 100 4 226 226 Yes 8/13/2008 1:34:55 COOLING OCCUPIE[ 799 761 100 5 240 240 Yes 8/13/2008 1:35:03 COOLING OCCUPIE[ 299 301 47 6 241 241 Yes 8/13/2008 1:35:07 COOLING OCCUPIE[ 559 549 80 4973 4400 Traverse Total 4519 Duct Leakage 3% Project: Gateway 7 Phase 11 Report Date 8/13/2008 Time 2:27:03 Flow and Temp Balancing Report with Snapshot Data 2nd Floor Branch B Folder N Sub -Fok Box ID Zone Nami Balanced F Snapshot [ Snapshot 1 Controller t Occ State Flow Setpt Flow (CFM Damper Pos ( %) 1 227 227 Yes 8/13/2008 2:25:04 HEATING OCCUPIEE 1038 780 100 2 228 228 Yes 8/13/2008 2:25:08 COOLING OCCUPIEE 1038 555 100 3 233 233 Yes 8/13/2008 2:25:13 COOLING OCCUPIE[ 839 848 100 4 234 234 Yes 8/13/2008 2:25:17 COOLING OCCUPIEE 538 536 84 5 235 235 Yes 8/13/2008 2:25:20 COOLING OCCUPIE[ 890 657 100 6 236 236 Yes 8/13/2008 2:25:25 HEATING OCCUPIE[ 210 212 65 7 237 237 Yes 8/13/2008 2:25:29 COOLING OCCUPIEE 629 460 100 8 238 238 Yes 8/13/2008 2:25:32 COOLING OCCUPIE[ 339 343 85 9 239 239 Yes 8/13/2008 2:25:36 COOLING OCCUPIE[ 1460 1049 100 10 243 243 Yes 8/13/2008 2:25:39 COOLING OCCUPIE[ 519 436 100 7500 5876 Traverse Total 6082 Duct Leakage 3% DEPARTMENTS: %CAI OU•'.•� Building Division Public Works Complete Comments: APPROVALS OR CORRECTIONS: Approved Notation: REVIEWER'S INITIALS: Documents/routing slip.doc 2 -28 -02 • PERMIT COORD COPY PLAN REVIEW /ROUTING SLIP ACTIVITY NUMBER: M09 -076 DATE: 06 -17 -09 PROJECT NAME: GATEWAY BLDG 7 SITE ADDRESS: 12720 GATEWAY DR X Original Plan Submittal Response to Correction Letter # Response to Incomplete Letter # Revision # After Permit Issued U Structural DETERMINATION OF COMPLETENESS: (Tues., Thurs.) AA (9 Fire Prevention Incomplete Permit Center Use Only INCOMPLETE LETTER MAILED: Departments determined incomplete: Bldg ❑ Fire ❑ Ping ❑ PW ❑ Staff Initials: LETTER OF COMPLETENESS MAILED: TUES /THURS ROUTING: Please Route Structural Review Required 1 I No further Review Required n REVIEWER'S INITIALS: Approved with Conditions DUE DATE: 06-18-09 DATE: DATE: Planning Division Permit Coordinator Not Applicable DUE DATE: 07-16-09 Not Approved (attach comments) Permit Center Use Only CORRECTION LETTER MAILED: Departments issued corrections: Bldg ❑ Fire ❑ Ping ❑ PW ❑ Staff Initials: License Name Type Specialty 1 Specialty 2 Effective Date Expiration Date Status DIVCOI *988RC DIVCO INCORPORATION CONSTRUCTION CONTRACTOR GENERAL UNUSED 12/3/2002 11/7/2010 ACTIVE MACDOMR026RU MACDONALD MILLER RSDNTL INC CONSTRUCTION CONTRACTOR UNUSED GENERAL 12/31/1998 12/31 /2001 ARCHIVED MACDOMR0760P MACDONALD MILLER RESIDENTIAL CONSTRUCTION CONTRACTOR GENERAL UNUSED 9/17/1993 12/30/1998 ARCHIVED DIVCOEC188LC DIVCO ENERGY CONTROL COMPANY CONSTRUCTION CONTRACTOR GENERAL UNUSED 6/3/1982 5/26/1997 ARCHIVED MACDOM *248J9 MACDONALD MILLER CO CONSTRUCTION CONTRACTOR GENERAL UNUSED 4/29/1976 2/1/2002 ARCHIVED ENCOMMS984CA ENCOMPASS MECHANICAL SERVICES CONSTRUCTION CONTRACTOR GENERAL UNUSED 2/1/2002 2/1/2004 EXPIRED LINFOAR980QG LINFORD AIR 13 REFRIGERTN INC CONSTRUCTION CONTRACTOR GENERAL UNUSED 11/7/2002 11/7/2004 INACTIVE DIVCOI *031L4 DIVCO INC CONSTRUCTION CONTRACTOR GENERAL UNUSED 6/24/1997 8/1/2003 REREGISTERED Untitled Page • • General /Specialty Contractor A business registered as a construction contractor with Led to perform construction work within the scope of its specialty. A General or Specialty construction Contractor must maintain a surety bond or assignment of account and carry general liability insurance. Business and Licensing Information Name Phone Address Suite /Apt. City State Zip County Business Type Parent Company MACDONALD /MILLER FAC SOL INC 2067684180 PO BOX 47983 SEATTLE WA 98106 KING Corporation UBI No. Status License No. License Type Effective Date Expiration Date Suspend Date Specialty 1 Specialty 2 602254260 ACTIVE MACDOFS980RU CONSTRUCTION CONTRACTOR 12/31/2002 12/31/2010 GENERAL UNUSED Other Associated Licenses Page 1 of 2 Business Owner Information Name Role Effective Date Expiration Date https: // fortress .wa.gov /lni/bbip/Detail.aspx 06/30/2009 a ' FLOOR 2 ~��UN��K �: DUCT BOX SCHEDULE ,'- _- - _ _ -_-- - - � �� ' ^ ` UNIT NO. ' ' ' ` MFG & MODEL NO. INLET SIZE (IN) VALVE CFM ' CONTROLS LOCATION* ' ^ } NOTES MAX MIN \&'T-201 NA|LOR3OO1 - 12 320 160 RIGHT REBAL, EXISTING, 1,2,4 \8/T'202 NA|LOR3OU1 ' 12 370 110 LEFT - - ` EXISTING, 1,2,4 \8T-203 NAJUDR30U1 12 890 330 RIGHT EXISTING, 1,2,4 VVT-204 � ''�`'� ~u NA|LOR3OO1 12 300 90 LEFT EXISTING, 1,2,4 \8/T-205 NA|LOR3UO1 10 170 50 LEFT EXISTING, 1,2,4 VVT-208 NOT USED - - - - NOT USED VVT-2O7 NA|LOR3001 10 510 150 RIGHT EXISTING, 1,2,4 \8/T-208 NA|LDR3OO1 12 570 170 LEFT EXISTING, 1,2,4 VVT-209 NA|LOR3001 14 1020 290 RIGHT EXISTING, 1,2,4 \yVF-218 NA|LOR3OO1 12 440 130 RIGHT EXISTING, 1,2,4 \8/T-211 NA|LOR3UO1 14 1030 260 RIGHT EXISTING, 1,2,4 \0/T-212 NAJLOR3O01 12 490 100 LEFT EXISTING, 1,2,4 VVT-213 NA(LOR3UO1 12 270 80 LEFT EXISTING, 1,2,4 V\/[-214 NA|U]R3OU1 10 390 210 LEFT EXISTING, 1,2,4 V\/7-215 NA|LOR3O01 12 400 280 LEFT EXISTING, 1,2,4 VVT-216 NA|LOR3UU1 12 880 80 RIGHT EXISTING, 1,2,4 VVT-217 NA|LOR3O01 12 490 330 LEFT EXISTING, 1,2,4 VVT-218 NA|LOR3UO1 12 200 60 LEFT EXISTING, 1,2,4 VVT-219 / NA|UOR3O01 12 90 30 RIGHT EXISTING, 1,2,4 VVT-220 NA|LOR3OO1 12 320 100 LEFT EXISTING, 1,2,4 VVT-221 NAILOR 3001 12 280 80 RIGHT EXISTING, 1,2,4 ' \8/T-117 NA|LOR3OO1 12 210 60 \yVT-222 METAL INDUSTRIES 5Q8D 12 900 330 RIGHT NEW, REPLACE EXISTING VVT, 1,3,5,6 VVT-223 METAL INDUSTRIES 5Q8D 12 1040 330 RIGHT NEW, REPLACE EXISTING VVT,i.3.5.O VVT-224 METAL INDUSTRIES g08D 12 1120 330 RIGHT NEW, REPLACE EXISTINGVVT, 1.3.5.6 VVT-225 METAL INDUSTRIES 59OD 12 1160 330 RIGHT NEW, REPLACE EXISTING VVT,1.3.5.G VVT-226 METAL INDUSTRIES 5Q8C 10 800 210 RIGHT NEW, REPLACE EXISTING VVT, 1,3,5,6 VVT-227 METAL INDUSTRIES 598 D 12 1040 330 RIGHT NEW, REPLACE EXISTING WT, 1,3,5,6 VVT-228 METAL INDUSTRIES 5Q8D 12 1040 330 RIGHT NEW, REPLACE EXISTINGVVT, 1,3,5,6 VVT-229 METAL INDUSTRIES 598 E 14 810 400 RIGHT NEW, REPLACE EXISTING WT, 1.3.5.0 \8/T-230 METAL INDUSTRIES 5BBF 16 1220 630 RIGHT NEW, REPLACE EXISTING V\T,1.3.5.8 \8/T-231 METAL INDUSTRIES 598 F 16 2000 630 RIGHT NEW, REPLACE EXISTING WT, 1,3,5,6 WT-232 METAL INDUSTRIES SQOF 16 2160 030 RIGHT NEW, REPLACE EXISTING WT, 1,3,5,6 VVT-233 METAL INDUSTRIES 598 D 12 840 330 RIGHT NEW, REPLACE EXISTING VVT, 1,3,5,6 VVT-234 METAL INDUSTRIES 598 B 8 540 210 RIGHT NEW, REPLACE EXISTING VVT 1,3,5,6 VVT-235 METAL INDUSTRIES 598 D 12 890 330 RIGHT NEW, REPLACE EXISTING \8/T1.3.5.6 WT-236 UNKNOWN - - - METAL INDUSTRIES 598 B DEMO VVT-237 METAL INDUSTRIES S0O8 8 830 150 RIGHT NEW, REPLACE EXISTING VVT1.3.5.8 VVT-238 METAL INDUSTRIES 598 B 8 340 150 RIGHT NEW, REPLACE EXISTING \NT.1.3.5.8 VVT-239 METAL INDUSTRIES 5S8D 12 1460 380 RIGHT NEW, REPLACE EXISTING \x/T,1.3.5.G.7 VV7-240 METAL INDUSTRIES 598 B 8 300 150 RIGHT NEW, REPLACE EXISTING VVT, 1,3,5,6 \«/T-241 METAL INDUSTRIES 598 B 10 580 150 RIGHT NEW, REPLACE EXISTING WT 1.3.5.6 VVT-242 UNKNOWN - - - NEW, REPLACE EXISTING WT, 1.3.5.6 DEMO VVT-243 METAL INDUSTRIES 598 B 8 520 260 RIGHT NEW, REPLACE EXISTING VVT1.3.5.8 NEW, REPLACE EXISTING VVT 1.3.5.6 WT-134 'METAL INDUSTRIES 598D 12 1530 330 RIGHT NEW, REPLACE EXISTING \x/T.1.3.5.8 WT-135 METAL INDUSTRIES 5SDA 6 DAMPER LEGEND �� "� 1 - SINGLE DUCT D ��VT BOX ��E��UUK SCHEDULE FLOOR I --- - - - �� UNIT NO. 4�1 FSD � HFSD4 �� TFSD�00� FSD HFSD �@�� SD �&�� MD�� SCD �0� AD ' MFG & MODEL NO. INLET SIZE (IN) VALVE CFM CONTROLS LOCATION* NOTES MAX GREENHECKF8D212(2O0UFPW1)DREQUAL 8REENHECKFSD312(3OOOFPK4)OREQUAL 11/2 HOUR TUNNEL CDRFUOORCOK4B|NAT|ONF|RBSN0KE MIN \yVT-101 GREENHECK DFD 350 (HORIZONTAL MOUNT) OR EQUAL CEILING RADIATION NAILOR 3001 12 470 BDD BAR �� | 230 RIGHT REBAL, EXISTING, 1,2,4 \VT-102 '` ` SHOP FABRICATED, W/ LOCKING QUADRANT NAILOR3UU1 ` 12 860 AUTHORITIES. 340 RIGHT REBAL, EXISTING, 1,2,4 VVT-103 9 FOR CONDENSATE PIPING PROVIDE TRAPS WITH A MINIMUM SEAL 2" GREATER THAN THE FAN OPERATING STATIC PRESSURE AT ALL COOLING COIL CONNECTIONS. NAILOR 3001 12 1380 1.2 500 RIGHT REBAL, EXISTING, 1,2,4 VVT-104 24/24 NA|LOR3OO1 12 860 2ND SOUTH 330 LEFT EXISTING, 1,2,4 \8O-185 1 12 4/ NAILOR3OO1 12 520 3 160 RIGHT EXISTING, 1,2,4 VVT-106 NA|LOR3U01 12 350 - 110 LEFT EXISTING, 1,2,4 \8VT-107 CU-103 NAJLOR30O1 8 460 1200 140 RIGHT EXISTING, 1,2,4 \8/T-108 NA|UOR3OO1 12 640 - 190 LEFT EXISTING, 1,2,4 VVT-108 3 NA|LOR30O1 12 870 280 RIGHT EXISTING, 1,2,4 \yVl-110 NA1LOR3001 14 1100 EXIST, 1 330 RIGHT EXISTING, 1,2,4 \x/T-111 NA|LOR3001 8 340 100 LEFT EXISTING, 1,2,4 VVT-112 NA|bOR3001 8 220 ` 70 LEFT EXISTING, 1,2,4 VVT-113 ''^ NAJU]R3O01 12 840 250 RIGHT EXISTING, 1,2,4 VVT-114 ` NA|LOR3UU1 ' ' ' 12 800 ' 330 RIGHT EXISTING, 1,2,4 VVT-115 `� . NA]U]R3001 12 530 160 LEFT EXISTING, 1,2,4 VVT-116 NA1LOR3001 12 460 330 RIGHT EXISTING, 1,2,4 \8/T-117 NA|LOR3OO1 12 210 60 LEFT EXISTING, 1,2,4 WT-118 NA|U]R3O01 8 50 20 LEFT EXISTING, 1,2,4 VVT-119 NA|LOR3OO1 12 300 90 LEFT EXISTING, 1,2,4 \yv7-120 NAILOR3OV1 ' 10 180 50 LEFT EXISTING, 1,2,4 \8/T-121 NA|LOR3O01 10 360 110 RIGHT EXISTING, 1,2,4 VVT-122 NA|UJR3UU1 12 550 170 RIGHT EXISTING, 1,2,4 ` \x/T-123 METAL INDUSTRIES 598 C 10 1020 320 RIGHT NEW, REPLACE EXISTING WT, 1,3,5,6 \V7-124 METAL INDUSTRIES 5S8C 10 920 310 RIGHT NEW, REPLACE EXISTING VVT,1.3.5.8 VVT-125 METAL INDUSTRIES 598 C 10 780 . 320 RIGHT NEW, REPLACE EXISTING VVT1.3.S.O \8/T-126 METAL INDUSTRIES 598 D 12 1300 330 RIGHT NEW, REPLACE EXISTING 'Nt, 1.3.6.8 \yv7-127 METAL INDUSTRIES 598 D 12 1290 330 RIGHT NEW, REPLACE EXISTING VVT, 1,3,5,6 \8/T-128 METAL INDUSTRIES 598 B 8 490 150 RIGHT NEW, REPLACE EXISTING VVT, 1,3,5,6 VVT-129 METAL INDUSTRIES 5988 8 380 150 RIGHT NEW, REPLACE EXISTING VVT,1.3.S.6 \8/T-130 METAL INDUSTRIES 5S8C 10 1070 210 RIGHT NEW, REPLACE EXISTING Wt, 1.3.5.6 VVT-131 METAL INDUSTRIES 598 D 12 1300 330 RIGHT NEW, REPLACE EXISTING WT, 1.3.S.G V\T-132 METAL INDUSTRIES 5SD8 8 260 150 RIGHT NEW, REPLACE EXISTING WT, 1.3.5.6 \;o7-133 METAL INDUSTRIES 598 D 12 1240 330 RIGHT NEW, REPLACE EXISTING VVT 1.3.5.6 WT-134 'METAL INDUSTRIES 598D 12 1530 330 RIGHT NEW, REPLACE EXISTING \x/T.1.3.5.8 WT-135 METAL INDUSTRIES 5SDA 6 180 70 RIGHT NEW, REPLACE EXISTINGVVT, 1.3.5.6 VVT-136 METAL INDUSTRIES 598 B 8 400 150 RIGHT NEW, REPLACE EXISTING VVT, 1,3,5,6 VVT-137 METAL INDUSTRIES 598B 8 410 180 RIGHT NEW, REPLACE EXISTING \8/T,1.3.5.8 VVT-138 METAL INDUSTRIES 508C 10 480 330 RIGHT NEVV, REPLACE EX|ST|N8VVT 1.3.5.6 VVT-139 METAL INDUSTRIES 5S8D 12 1220 330 RIGHT NEW, REPLACE EXSTINGVVT, 1,3,5,6 DAMPER LEGEND �� "� SYMBOL DESCRIPTION-POWERED SYMBOL DESCRIPTION-NON POWERED 4�1 FSD � HFSD4 �� TFSD�00� FSD HFSD �@�� SD �&�� MD�� SCD �0� AD 11/2 HOUR VERTICAL CON\B�N/�lONFIRE/SMOKE FD ��G� �� HFD � �G� FD �0� �� HFD �� 0� FD 4�Nr ", 11/2 HOUR OUF�7\|NSTYLE VERT|{�LFIRE DAMPER GREENHECKDFO15OOFlEQUAL 11/2 HOUR CURTAIN STYLE HORIZONTAL FIRE DAK4pER 8REENHEOKFSD212(2OOOFPK�)OREQUAL GREENHECK FSD 312 (3000 FPM) OR EQUAL 1 1/2 HOUR HORIZONTAL COMBNATION FIRE/SMOKE GREENHECK DFD 150 (HORIZONTAL MOUNT) OR EQUAL HOUR CURTAIN STYLE VERT!CAL FIRE DAMPER GREENHECKF8D212(2O0UFPW1)DREQUAL 8REENHECKFSD312(3OOOFPK4)OREQUAL 11/2 HOUR TUNNEL CDRFUOORCOK4B|NAT|ONF|RBSN0KE GREENHECK DFD 350 OR EQUAL HOUR CURTAIN STYLE HORZONTAL FIRE DAMPER �� [�REENHECKCFSD212'1OREOUAL � 3 HOUF�VERTICAL COW1B|NAOONF|RBSW1OKE GREENHECK DFD 350 (HORIZONTAL MOUNT) OR EQUAL CEILING RADIATION �� GREENHECKFSD23iDREQUAL . 3 HOUR COK�8|NAT|ON FIRE/SMOKE � GREENHECK CRD-2 OR EQUAL BACKDRAFTOAK4PER ~, GREEN CKFSD231OREC\UAL SMOKE DAMPER BDD BAR �� | (HORIZONTAL) ' OR EQUAL BAROMETRIC RELTEF DAMPER (.05 OPNG PRESSURE SHOWN) �� QREENHBCKSK�D2O2OREQUAL MOTORIZED CONTROL DAMPER � ,- RUSK|NCBD2NO SUBSTITUTE ALLOVVED VOLUME DAMPER �� QREENHEC�VCD�3OREOUAL S&1ONCONTROLK8OTOR|ZEDDAMPER 8REENHECKSK8D3O1OREQUAL '` ` SHOP FABRICATED, W/ LOCKING QUADRANT �� |NTERLOCKVV|THF|REALARK4BYELECTR([AL CONTRACTOR ACCESS DOOR 18^ .. 1 MINIMUM THROUGH BUILDING CONSTRUCTION BY GENERAL ~-~_ -^-�^ AUTHORITIES. GENERAL NOTES: COMBINATION FIRE/SMOKE DAMPER REQUIREMENTS (UNLESS OTHERWISE NOTED): -CLASSU l 165° ' \ � . -FA|L-CLOSE.i2UVACTUATOR ' ACTUATOR BYK4ECHAN|CALC TRACTORVV|R|NGBYELECTR|CALCC�NTRACTOR '|NTERLOCK FIRE ALARM SYSTEM BY ELECTRICAL CO R FtRE DAMPER REQUIREMENTS: - BLADES OUT OF AIRSTREAM ONMEDIUM PRESSURE DUCTS - 165 F FUSIBLE UNK - CLASS || �� GENERAL NOTES PIPING �0PN� SCHEDULE: MATERIAL ' ^ PIPING ' SIZE MATERIAL JOINT 1/2"-2^ SCH4OBLKGTL ASTM A53 A OR B THREADED, FLANGED, SOCKET WELDED NATURAL GAS WT LBS SCH 40 BLK STL BUTT WELDED TYPE 2-1/2"-10^ ASTM A53 A OR B FLANGED, 1. THESE PLANS ARE SCHEMATIC AND P0 NOT SHOW EXACT ROUTING OR EVERY OFFSET WHICH MAY BE REQUIRED. THE MECHANICAL CONTRACTOR IS TO COORDINATE WITH ALL OTHER TRADES AND IS TO VERIFY ALL CLEARANCES BEFORE COMMENCING WORK. 2. MATERIALS, METHODS, AND INSTALLATION SHALL COMPLY WITH THE PROVISIONS OF THE 2006 IBC, IMC, AND UPC AS AMENDED BY THE STATE OF WASHINGTON AND LOCAL AUTHORITIES. 3_ ALL PIPE SIZES NOTED ON DRAWINGS ARE MINIMUMS. 4 - SLOPE ALL INDIRECT DRAINS AT 2% UNLESS OTHERWISE NOTED ON DRAWINGS. OBTAIN APPROVAL FROM CODE AUTHORITY BEFORE INSTALLING PIPING AT LESS THAN 2% (EVEN IF LESSER SLOPE 15 INDICATED ON DRAWINGS). 5. HANGERS AND SUPPORTS FOR PIPING SHALL BE IN ACCORDANCE WITH THE 2006 IMC AND IBC AS AMENDED BY THE STATE OF WASHINGTON AND LOCAL AUTHORITIES. 6. PIPI QPENETRAT|ON3OFFIRERATEDVVALLSORFLODRGGHALLBE8LEEVEDANDF|RESTOPPEDVV|THL|STEDMATER|ALSSOASTOMA|NlA|NTHE|NTEGR|TYANO RATING OF THE FLOOR OR WALL. 7 PROVIDE SHUTOFF VALVES AT ALL EQUIPMENT CONNECTIONS 8 PROVIDE UNION, GROOVED OR FLANGED CONNECTION AT EQUIPMENT FOR FUTURE REMOVAL AND SERVICING. 9 FOR CONDENSATE PIPING PROVIDE TRAPS WITH A MINIMUM SEAL 2" GREATER THAN THE FAN OPERATING STATIC PRESSURE AT ALL COOLING COIL CONNECTIONS. 10 PROVIDE MINIMUM 1" AIR BREAK FOR ALL CONDENSATE PIPE TERMINATIONS AT DRAINS. 11 PROVIDE DIELECTRIC CONNECTIONS BEWEEN DISSIMILR METALS -- ' DX CONDENSING UNIT SCHEDULE UNIT NO. '' MFG & MODEL NO. ARI COOL TONS EER/ IPLV COMPRESSOR NO. REF CIRCUITS SUC LINE (IN) LIQ LINE (IN) ELECTRICAL CONTROL WT LBS NOTES NO. TYPE HP EACH RPM VOLT/PH MCA CU401 RHEEM RAKA-037DAZ 3 SHOEMAKER 701-MA BARE FLAT OVAL SHEETMETAL T-BAR LAY-IN MODULAR CORE DIFFUSER 14/12 W 1 4/12*� 150 1-6 ----''''-` 8AREROUNDSHEETMElAL M-M METAL EGGCRATE FLAT OVAL FLAT SHEETMETAL W/ INSULATION (2") RETURN/EXH 120 EXIST, 1 1.2 1010 EXPOSED QUALITY SHEETMETAL 8�21 DUCTBOARD (1" FIBERGLASS) 24/24 14/12 Q 14/12 DB CARRIER � 601QE SERIAL# 4194G30497 2ND SOUTH ��PUEOFNBN / - EXAMPLE CONTRACT IN ----�7l�---- __ 1 12 4/ CU-102 RHEEM RAKA-037DAZ 3 � ��lJ\J`~ x x x x x x x x x xxxxxxx EXAMPLE OF EXISTING FLEX CONNECTOR 14/12 - - - 24V EXIST, 1 CU-103 RHEEM RAKA-087DAZ 3 ' RHEEM RAKA-O37OAZ 1200 `^ 0 - - - 24V EXIST, 1 CU-104 RHEEM RAKA-037D/Z 3 EXIST, 1 FCU-201 CU-201 ` EXIST ABANDONED DUCT ��~° ��"°� DESCRIPTION SYMBOL DESCRIPTION SYMBOL BARE SHEETMETAL 0 ROUND SHEETMETAL WRAPPED W/ INSULATION (2") SUPPLY CFM 14/12 12m VV EXISTING, CF W 8DUNDUNESHEETMET4LM^LINING) CLEANROOM QUALITY DUCTWORK AS NOTED 14/12 SL 14/12 C CF� '(0 SHEETMETAL WRAPPED W/ INSULATION (2") SHOEMAKER 701-MA BARE FLAT OVAL SHEETMETAL T-BAR LAY-IN MODULAR CORE DIFFUSER 14/12 W 1 4/12*� 150 1-6 ----''''-` 8AREROUNDSHEETMElAL M-M METAL EGGCRATE FLAT OVAL FLAT SHEETMETAL W/ INSULATION (2") RETURN/EXH 120 14/12*aW 1.2 1010 EXPOSED QUALITY SHEETMETAL 8�21 DUCTBOARD (1" FIBERGLASS) 24/24 14/12 Q 14/12 DB CARRIER � 601QE SERIAL# 4194G30497 2ND SOUTH ��PUEOFNBN / - EXAMPLE CONTRACT IN ----�7l�---- __ 1 12 4/ E�MPBOFO�O 460/3 FLEX � ��lJ\J`~ x x x x x x x x x xxxxxxx EXAMPLE OF EXISTING FLEX CONNECTOR 14/12 - - - ��UU��&��KU��U� �� ~~°~�"�"��"�"~�~�� SCHEDULE SYMBOL MANUFACTURER & MODEL NUMBER SIZE TYPE NOTES 0 S\ZE SUPPLY CFM AS NOTED T�AR LAY-IN K4ODULARCORE DIFFUSER EXISTING, CF W POWER EXH MOTOR S|ZE MCA AS NOTED RETURN/EXH EXISTING CF� '(0 1@30 SHOEMAKER 701-MA AS NOTED T-BAR LAY-IN MODULAR CORE DIFFUSER NEW 480/3 150 1-6 ----''''-` `-� M-M METAL EGGCRATE 12/24 RETURN/EXH 7�00 [| 1.2 1010 `` 8�21 - M-M METAL EGGCRATE 24/24 RETURN/EXH ~ PACKAGED GAS/ELEC ��d�N��N�U��d� ROOFTOP UNIT SCHEDULE " "�~�"~"�~~~~~~ ~�"�~" "~~~�~~~ AIR ~,~~"��°"~"~~"�""=~° "�.�~~� " ~~' .�.... ~~~~..~~~~.~~~~~ UNIT NO. � - ' bNFG&&�NO0�L0�� ' AREA �� SERVED FANS WEIGHT (LBS) ELECTRICAL NOTES SUPPLY CFM (CFM) SUPPLY MOTOR (HP) ESP (IN) RPM POWER EXH MOTOR VOLT/ PH MCA RTU' O1 '``""'°"^"~"~"' 1H� EAST �O�OO 3�OO 1@30 1.2 1242 117UOCFM 4��1HPEAJ�H G�68 480/3 150 1-6 ----''''-` `-� - CARR(ER 1H/N ^'""""","' WEST 24�0O 7�00 1@30 1.2 1010 1T.550CF� 0��1HP 8�21 480/3 174 NEVV REPL 8 ' T E�|8.3 RTU-103 CARRIER � 601QE SERIAL# 4194G30497 2ND SOUTH 5.000 - 1@4 2 BHP 12 1140 1287 460/3 36 EXISTING 8 DX �� - FAN COL UNIT SCHEDULE _----_ ''-__-__'' UNIT NO. AREA SERVED MFG & MODEL NO. BLOWER OSA CFM ELECTRICAL HEAT CONTROL WT LBS NOTES CFM ESP HP RPM VOLT/PH MCA VOLT/PH KW STG FCU'101 LAB 3 RHEEM RAKA-037D/Z 1200 5 82 RTU-102 0 60 682 - - - 24V 1164 REBAL, EXISTING, 2 FCU-102 LAB 2 NORTH RHEEM RAKA-037DAZ 1200 1�5 158 118 0 O.85 R-%2 - - - 24V REBAL, EXISTING, 2 FCU-103 LAB 2 SOUTH RHEEM RA0A-O37OAZ 1200 0 - - - 24V REBAL, EXISTING, 2 FCU-104 LAB 1 RHEEM RAKA-O37OAZ 1200 0 - - - 24V REBAL, EXISTING, 2 FCU-201 EXISTING, ABANDONED,1 � UNIT NO. ^ MFG & MODEL NO. COOLING HEATING COOLING TOTAL ' COOLING TOTAL (MBH) COOLING SENS (1111BH) 'EER/ SEER IPLV REFER TYPE HEAT INPUT (MBH) HEAT OUTPUT (MBH) STAGES (#) AFUE ( %I RTV40 CARRIER 48AKTO5ODSQ611HM 50 600 456 9.3/ 9.5 R-22 800 656 5 82 RTU-102 CARRIER 1HM 60 682 . 544 10.10 9.5 R-410A 1164 954 9 82 RTU-1O3 ^ CARR|ER48TJD014SERES# 1�5 158 118 O.8/ O.85 R-%2 225 180 2 80 PARALLEL VAV BOX SCHEDULE UNIT NO. MFG & MODEL NO. INLET SIZE VALVE CFM HEATER FAN NOTES MAX MIN KW DT CFM VOLT/PH STGS HP VOLT/PH SPD VAV-201 NA|LOR35NE SIZE 2 8 260 80 3.0 30 310 480/3 1 1/10 277/1 - EXISTING, 1.2.3.4.8 \6AV-202 NAILOR 35NE SIZE 3 ' ' � 10 910 210 5.0 21 760 277/1 2 1/4 277/1 - NEW, 1,2,3,5 oD � o NOTES: - 1 ELECTRICAL DISCONNECT SWITCH AND POWER WIRING 8Y ELECTRICAL DISCONNECT SWITCH AND 2.VFD MOTORS 3. FEATURES AND OPTIONS INCLUDED: -COK4FORTLNK CONTROLS WITH 'VISUAL SCROLLING MARQUEE D�PLAY - HIGH GAS HEAT VV�H STAINLESS HEAT EXCHANGER/BURNER ' AL/CU COND AND EVAP - DIFFERENTIAL DRY-BULB ECONOMIZER - FACTORY INSTALLED POWER EXHAUST - HOT GAS BYPASS - BACNET TRANSLATOR CONTROLS INTERFACE - RETURN AIR SMOKE DETECTOR .. 115V FACTORY WIRED CONVENIENCE OUTLET ' CO2 SENSOR 4. MAXIMUM SOUND POWER LEVEL OF 99 DECIBELS RATED IN ACCORDANCE WITH ARI STANDARD 270 5. NEW UNIT WEIGHT (O.G58 LBS) |S LESS THAN UNIT REPLACED (S.80ULBS). NO STRUCTUR LREy|EWREQU|REDPERC|TYOFTU0N|LA. 6. MAXIMUM SOUND POWER LEVEL OF 100 DECIBELS RATED IN ACCORDANCE WITH ARI STANDARD 270 * OF CONTROLS ON VVT BOX BASED ON LOOKING IN DIRECTION OF AIRFLOW (AIR HITTING BACK OF HEAD) NOTES: 1. FACTORY TOGGLE INTERLOCKING DISCONNECT 2. W/ LOW VELOCITY MULTIPOINT AVERAGING FLOW SENSOR 3. W/ FACTORY STANDARD K4ULT|PO|NT AVERAGING FbJVVSENSOR 4. CONFIGURED FOR FIELD MOUNTED STAEFA DDC CONTROLS PROVIDED BY MECHANICAL CONTRACTOR ' 5. ORDERED W/ FACTORY STANDARD RIGHT-HAND CONFIGURATION. FIELD TO FLIP BOX IN FIELD AS NECESSARY TO MAINTAIN CONTROL BOX CLEARANCES. 6. W/ FACTORY MOUNTED DDC CONTROLS PROVIDED BY FACTORY. * LOCATION OF CONTROLS ON WT BOX BASED ON LOOKING IN DIRECTION OF AIRFLOW (AIR HITTING BACK OF HEAD). NOTES: 1. FACTORY TOGGLE INTERLOCKING DISCONNECT 2. W/ LOW VELOCITY MULTIPOINT AVERAGING FLOW SENSOR 3. W/ FACTORY STANDARD MULTIPOINT AVERAGING FLOW SENSOR 4. CONFIGURED FOR FIELD MOUNTED STAEFA DDC CONTROLS PROVIDED BY MECHANICAL CONTRACTOR 5. ORDERED W/ FACTORY STANDARD RIGHT-HAND CONFIGURATION. FIELD TO FLIP BOX IN FIELD AS N TO MAINTAIN CONTROL BOX CLEARANCES. 6. W/ FACTORY MOUNTED DDC CONTROLS PROVIDED BY FACTORY. 7. VENTILATION CONTROL BY ROOM CO2 SENSOR PROVIDED AND INSTALLED BY M-M. NOTES: 1. DIFFUSERS TYPICALLY LABELED WITH EXTERIOR DIMENSIONS, 24x24 FOR SQUARE DIFFUSERS AND 6x48 FOR SLOT DIFFUSERS. NOTES: 1. NO INFORMATION ON THIS UNIT, ABANDONED |N PLACE. I. UNIT FORSPACE COOLING ONLY, ZERO MIN OSA, VENTILATION AIR PROVIDED BY EXISTING BUILDING HVAC SYSTEM. NOTES: 1. FIELD LOCATE UNIT, COMPLETE INFORMATION IN SCHEDULE FROM EQUIPMENT TAG AND MARK UNIT LOCATION ON THE AS-BUILT DRAWING. NOTEG 1. POWER WIRING AND DISCONNECT SWITCH BY ELECTRICAL CONTRACTOR 2. W/ MULTIPOINT AVERAGING FLOW SENSOR ^ 3. CONFIGURED FOR FIELD MOUNTED STAEFA DDC CONTROLS PROVIDED BY MECHANICAL CONTRACTOR 4. LEFT HAND SIDE CONTROLS ENCLOSURE LOCATION BASED ON LOOKING IN DIRECTION OF AIRFLOW (AIR HITTING BACK OF HEAD). 5. RIGHT HAND SIDE CONTROLS ENCLOSURE LOCATION BASED ON LOOKING IN DIRECTION OF AIRFLOW (AIR HITTING BACK OF HEAD). 0. ELECTRIC HEAT INSTALLED WWITH 3 WIRES AT 277V/1 PH WHICH RESULTS IN REDUCED HEATING CAPACITY Sebbical Plumbing Gas Piping SEPARATE PERMIT REQUIRED FOR: 6 I City of Tukwila BUILDING ^ 7717 Detroit Avenue SW Seattle, WA 98106 Phone: Fax: 206-767-6773 www.macmiller.com CD-PERMIT SET REVISIONS: CHECKED BY: B GEZON CAD: D IKERD LAST REVISED: O5-21_O@ DATE PLOTTED: O5 ISSUE DATE: 05-22-08 DATE GATEWAY �� wrno �~nn��n ��u~�� PHASE 2 12720 GATEWAY DR S TUKWILA WA 98168 DRAWING NUMBER: E -7386215-00 SHEET NUMBER: HVAC GENERAL NOTES 1 . THESE PLANS ARE SCHEMATIC AND DO NOT SHOW EXACT ROUTING OR EVERY OFFSET WHICH MAY BE REQUIRED. THE HVAC CONTRACTOR 15 TO COORDINATE WITH ALL OTHER TRADES AND IS TO VERIFY ALL CLEARANCES BEFORE COMMENCING WOR / - 2. MATERIALS, METHODS, AND INSTALLATION SHALL COMPLY WITH THE PROVISIONS OF THE 2006 EDITIONS OF THE INTERNATIONAL MECHANICAL CODE, INTERNATIONAL BUILDING CODE, INTERNATIONAL FIRE CODE AND STATE AND LOCAL CODES AND ORDINANCES. 3. DUCT CONSTRUCTION AND HANGING SHALL COMPLY WITH CHAPTER 6 OF THE 2006 IMC AND WITH CURRENT SMACNA STANDARDS 4. JOINTS OF MEDIUM AND HIGH VELOCITY DUCT SYSTEMS SHALL BE SEALED WITH GASKETS OR LISTED MASTIC TYPE DUCT SEALANT. 5. DUCTS SHALL BE INSULATED AS INDICATED ON PLANS, PER 2006 WSEC - DUCT WRAP, WHERE INDICATED, SHALL BE 1 1/2" 0.75 LB/CU FT FIBERGLASS DUCT INSULATION WITH A FACTORY APPLIED REINFORCED ALUM. FOIL VAPOR BARRIER (R-4.2 MIN.). - SOUND LINING, WHERE INDICATED, SHALL BE 1" 1.5 LB/CU FT FIBERGLASS DUCT LINING COATED TO PREVENT FIBER EROSION AT VELOCITIES UP TO 6000 FPM (R-4.2 MIN.). - DUCT BOARD, WHERE INDICATED, SHALL BE 1" RIGID FRK FACED El 475 FIBERGLASS DUCT BOARD SYSTEM, UL 181 LISTED AS A CLASS 1 AIR DUCT (R-4.3 MIN.). 6. FLEX DUCTS SHALL CONSIST OF A REINFORCED VAPOR BARRIER, 1 1/2" FIBERGLASS INSULATION, AND NON-PERFORATED INTERIOR LINER WITH WIRE HELIX. DUCT SHALL BE A UL 181 LISTED CLASS 1 AIR DUCT FLEX DUCTS SHALL ONLY BE USED WHERE SHOWN AND SHALL NOT EXCEED 8' IN LENGTH UNLESS NOTED OTHERWISE. 7. PROVIDE EARTHQUAKE RESTRAINT FOR HVAC EQUIPMENT IN ACCORDANCE WITH SECTION 1613 OF THE 2006 IBC. 8. PIPING PENETRATIONS OF FIRE RATED WALLS OR FLOORS SHALL BE SLEEVED AND FIRE STOPPED WITH LISTED MATERIALS SO AS TO MAINTAIN THE INTEGRITY AND RATING OF THE FLOOR OR WALL. DETECTOR AUTOMATIC RAUTO�/�'| HEATING, COOLING, VENTILATION ING IN EXCESS OF 2000 CFM |N ACCORDANCE WITH SECTION GOGOF THE 2OOG|W1O. POWER AND INTERLOCK WIRING WITH THE BUILDING FIRE ALARM SYSTEM IS BY THE ELECTRICAL CONTRAClT}R. 10.HVAC EQUIPMENT, VALVES AND DAMPERS SHALL BE LOCATED IN EASILY ACCESSIBLE LOCATIONS. UNLESS SHOWN ON ARCHITECTURAL DRAWINGS, REQUIRED ACCESS PANELS SHALL BE PROVIDED AND INSTALLED BY THE GENERAL CONTRACTOR. - 11. MOTOR STARTERS NOT LISTED AS BEING PROVIDED IN THE HVAC EQUIPMENT SCHEDULES ARE TO BE PROVIDED AND INSTALLED BY THE ELECTRICAL 12. WITHIN 90 DAYS AFTER THE DATE OF SYSTEM ACCEPTANCE, RECORD DRAWINGS OF THE ACTUAL INSTALLATION TO BE PROVIDED TO THE BUILDING OWNER RECORD DRAWINGS SHALL INCLUDE AS A MINIMUM THE LOCATION AND PERFORMANCE DATA ON EACH PIECE OF EQUIPMENT, GENERAL CONFIGURATION OF DUCT AND PIPE DISTRIBUTION SYSTEM, INCLUDING S(ZEG.AN�}THE TERMINAL AIR AND VVATERDEG|{�NFLOVVRATES. 13. OPERATING AND MAINTENANCE MANUALS TO BE PROVIDED TO THE BUILDING OWNER THAT INCLUDE SUBMIUAL DATA NAMES AND ADDRESSES OF AT LEAST ONE SERVICE AGENCY, HVAC CONTROLS SYSTEM MAINTENANCE AND CALIBRATION INFORMATION AND A COMPLETE OPERATIONAL NARRATIVE FOR EACH SYSTEM. 14.COMMISSIONING IS REQUIRED ON TH WASHINGTON STATE ENERGY CODE SECTION 1416 AND WITH LEED NC-2.1 FUNDAMENTAL BUILDING SYSTEMS COMMISSIONING AND ADDITIONAL COMMISSIONING 15.A COMPLETE REPORT OF TEST PROCEDURES AND RESULTS SHALL BE PREPARED AND FILED WITH THE OWNER. 1 6. DAMPERS USED FOR OUTDOOR AIR INTAKE, EXHAUST, OR RELIEF SHALL HAVE THE FOLLOWING MAXIMUM LEAKAGERATES AT 1 " W.G. (PER AMCA STANDARD 500): MOTORIZED DAMPERS: 10 CFMkS.F. GRAVITY DAMPERS: 20 CFM/S.F. (40 CFM /S.F. FOR DAMPERS SMALLER THAN 24 INCHES IN EITHER DIMENSION). 17.OUTS|DEA]R INTAKE, EXHAUST, ANDRELEF DAMPERS SERV|NGCONDITK]NEDSPACE8MUSTBEMOTORIZEDUFAIL PER WSEC 1412.4.1, EXCEPT AS ALLOWED BY WSEC. ABBV FULL NAME A COMPRESSED AIR LINE AC AIR CONDITIONING UNIT AFF ABOVE FINISHED FLOOR AL ALUMINUM BDD BOB BOD BOTT BTU BTUH BWG BWR C CAP CC CFM CHWR CHWS COMB CONN CWR CWS DB DIFF DMPR DN EC EGO EER ELEV EMS REVISIONS No changes shall be made to the scope of work without prior approval of Tukwila 8 will Building Division. 0 ��vou��Q�~ require a new plan / and may plan �-----''~�' v .�v�mQ��U��|��L fees. � ' _ � BACKDRAFT DAMPER BOTrOM OF BEAM BOUOM OF DUCT BOTTOM BRITISH THERMAL UNITS BRITISH THERMAL UNITS PER HOUR BOTrOM WALL GRILLE BOTrOM WALL REGISTER '^ CONDENSATE CAPACITY CONTROLS CONTRACTOR CUBIC FEET PER MINUTE CHILLED WATER RETURN CHILLED WATER SUPPLY COMBUSTION CONNECT CONDENSER WATER RETURN CONDENSER WATER SUPPLY DUCT BOARD DIFFUSER DAMPER DOWN ELECTRICAL CONTRACTOR EGGCRATE ENERGY EFFICIENCY RATIO ELEVATION ENERGY MANAGEMENT SYSTEM DRAWING SHEET K�� ~"�"��°""�~� �~""~�~�" ""~�°�� NAME TITLE NAME TITLE TMO.01 SCHEDULES - HVAC TM0.01S SITE MAP DK42.01 1ST FLOOR DEMO PLAN - HyAC TM2.01 1ST FLOOR PLAN _H\8\O DK42.02 2ND FLOOR DEMO PLAN 'HVAC TM2.02 2ND FLOOR PLAN - HVAC TM2.03 ROOF PLAN AND ELEVATION - HVAC CONTACT LIST TITLE NAME --' - COMPANY PHONE NUMBER FAX NUMBER PROJECT MANAGER PROJECT ENGINEER SHEETMETAL FOREMAN AIR BALANCE FOREMAN ELECTRICAL FOREMAN CONTROLS FOREMAN REFRIGERATION FOREMAN STEVE FLINK CHRIS LEE LARRY HARBISON BRAD SHARP MIKE MCGIVERN SABRINA WORKMAN STEVE HARBISON OPERATIONS MANAGER GREG COLEMAN MACDONALD MILLER MACDONALD MILLER MACDONALD MILLER MACDONALD MILLER MACDONALD MILLER MACDONALD MILLER MACDONALD MILLER RREEF 253'O81 206-768-4266 2064234294 208'768-4112 206-788~4048 206-788-4074 206-768-4032 206-788-4404 206-768-253-681-3173 206-768-4267 206-768~4295 206-788-4047 208'768-4075 288-788-4033 SCOPE OF WORK REPLACE (1 ) EXISTING PACKAGED ROOFTOP UNIT, INCLUDES NEW M-M CUSTOM FABRICATED CURB ADAPTER. UNIT. RECONNECT EXISTING NATURAL GAS LINE To ROOFTOP ELECTRICAL DISCONNECT/CONNECT FOR NEW ROOFTOP UNIT. REPLACE (37) EXISTING VVT BOXES. DEMO (2) VVT BOXES. INSTALL (1) PARALLEL VAV BOX WITH ELECTRIC HEAT. MODIFICATION OF EXISTING LOW PRESSURE DUCT AS SHOWN ON THE DRAWINGS NEW STAEFA CONTROLS SYSTEM FOR NEW VAV BOXES. INSTALL (1) CO2 SENSOR. AIR BALANCE (1) RTU, (41) WT BOXES (1) PARALLEL \0\V BOX, AND WQFANCO|LUNITS. LEGAL DESCRIPTION APN # 2716000070 LEGAL DESCRIPTION: GATEWAY CORPORATE CENTER PARCEL B OF CITY OF TUKWILA SHORT PLAT NO 89-1-SS RECORDING NO 8904120877 SD SHORT PLAT DAF - LOT 7 OF GATEWAY CORPORATE CENTER HVAC ABBREVIATIONS ABBV FULL NAME ESP EXTERNAL STATIC PRESSURE EXH EXHAUST EXTR EXTRACTOR FAC FIRE ALARM CONTRACTOR FD FIRE DAMPER FLA FOB FOT FSD G GALV GC GPM ER GWB HG HP HWR HWS ID INT LIQ �'' M-M MBH MC MCA MD MIN MT MUA NOM FULL LOAD AMPS FLAT ON BOTTOM FLAT ONTOP FIRE SMOKE DAMPER GAS LINE GALVANIZED GENERAL CONTRACTOR GALLONS PER MINUTE GRILLE GYPSUM WALL BOARD HOT GAS LINE HORSE POWER HOT WATER RETURN HOT WATER SUPPLY INSIDE DIMENSION INTERLOCK LIQUID LINE MACDONALD-MILLER ONE THOUSAND BTUH MECHANICAL CONTRACTOR MINIMUM CIRCUIT AMPAC|TY MOTORIZED MINIMUM MOUNT MAKE-UP AIR NOMINAL INTERURBAN AVE S VICINITY ��^�� U��UU`NUU � MAP NO SCALE ABBV FULL NAME OSA OUTSIDE AIR OBD OPPOSED BLADE DAMPER OD OUTSIDE DIMENSION RA RETURN AIR . REG REGISTER (GRILLE WITH DAMPER) REQ'D REQUIRED RIO ROUGH IN ONLY SA SUPPLY AIR SCD SMOKE CONTROL DAMPER SD SMOKE DAMPER SL SOUND LINING SM SHEET METAL SP STATIC PRESSURE SS START/STOP SSSC SOLID STATE SPEED CONTROLLER BI STEEL SUC SUCTION LINE SUSP SUSPENDED TSTAT THERMOSTAT TC TEMPERATURE CONTROL TOD TOP OFDUCT TOS TOP OFSTEEL TV TURN VANES TWG TOP WALL GRILLE 'TNR TOP WALL REGISTER TYP TYPICAL UNO UNLESS NOTED OTHERWISE VD VOLUME DAMPER VFD VARIABLE FREQUENCY DRIVE VOLTAGE PHASE & DUCT DIAMETER DUVK4WiSH RIVER 48TH AVE S � REVIEWED ��• /�� U ^ ^ '--' -- U GE APPROVE ��AM �`�"n�� ~~_� JUN �� AM� �`�"n �� ~~_- � City �� 8 ~�"� `~^ '_-- BUILDING DIVI U�� FILE C PY Permit �x� �~�7 No. � ��V \ w �m � 0s��|��i�� «�*""�°~°�~�°�"�°=^��~~~~ Approval of d mmds does not authorize the violalion of any adopted code or ordinance. R:-p-ipt of approved Field Copy and • It' • ns is acknowledged: �� ~3 , �J - �� City �� w�� ~�" °"rk°°"a BUILDING D ION tes-- 014P RECEIVED CITY OF TUKWILA ]Uw� ��DOO ,°'.~� �wv� PERMIT CENTER 0&�U N�� N�� N&��NN N��N��JU��N0�"�N��NNNN��N� m�m��m�,��m�'00��~*° ��mm=��m FACILITY SOLUTIONS n ��om~nn u ��m~��nu��u�� o I _ � m o m CO LIJ � m m CO m co 0 � CO 0 0 N N 0 2 0 0 co CL a) c a) N N O REVIEWED FOR CODE COMPLIANCE APPROVED JUN 2 5 2009 City of Tukwila BUILDING DIVISION MOc1 O7(p CITY ©F JUR7 2009 PERMITtENTER 7717 Detroit Avenue SW Seattle, WA 98106 Phone: 206- 763 -9400 Fax: 206- 767 -6773 www.macmiller.com WA LIq.No MACDOFS980RU I EXPIRES 7 16112 7 N CD— PERMIT SET REVISIONS: 05 -22 -08 DATE GATEWAY BLDG 7 PHASE 2 12720 GATEWAY DR S TUKWILA WA 98168 SITE MAP ENGINEER: LAST REVISED: C LEE 05 -21 -08 CHECKED BY: DATE PLOTTED: B GEZON 05 -21 -08 CAD: ISSUE DATE: D IKERD 05 -22 -08 DRAWING NUMBER: E- 0182- 7386215 -00 ISSUED FOR CONSTRUCTION SHEET NUMBER: TM0.01S MacDonald - Miller FACILITY SOLUTIONS 0 0 O I 0 I- I LO N CO rte) N H- U) 0 0 z W 0 0 (./) N W O- N co O O N (I) oo C.L. N 140 FCU - 1 0 FCU - -1 04 200 RA _ 4x24 WT -1,1.5 _. 140 RA'_ VJT =.113. 80 OP 3) 6x48 ! 6x48 50 125 24x24 \ --122 22x18 \N -108 IT'STAT-18I 16x16 RA; T STAT -03 - fY 0. N X _N_ N IT'STAT -191 12x 24x24 12x24 24x24 FCU -4'Q1 12x24 2x24 FCU -1:03 24x24 12x24 8'. _. (P..__.2) IT'STAT -081 IT'STAT -071 T'STAT -.1 11 (T'STAT-211 24x24 140 EA 12 _.2_ WT -114 24x24 T'STAT -23 ...... .. ..... 6x48 90 '" -6x48 24x24 W T -1 .2 1 T' STAT -401 (T'STAT -371 24x24 24x2 I- T'STAT -251 .180 mor:Amil .c. _d 80 10 v,1�.6x 48 ... .. (• ; 50 te . A y�� lf► n Rai NI W * I �.... WT -121 10 I 11'STAT 4 34I 6x48 12X24 24x24 24x24 24x24 4x24 SA. 24x24 WT -105A .. WT 1-05 - WT-110 24x24 X i LHIV ( 106 24x24 1.30. IT'STAT -301 T'STAT 291 IT'STAT -321 6x 45 ® 24x24 80 (TIP 6) 24x12 80 (TYP 3) TYP 2 80 (TYP 3) 100 (TYP 4) ®12x24 (TYP 4) 80 (TIP 4) (12x24 (TYP 4 100 (TYP 3) J 1 80 (TYP 4) ( 24x2 12x24 TRANSFER (TYP 3) 80 (TYP 5) 16x16 EA UP (80 (TYP 5) I 120 (TYP 2) 80 (TYP 4) 120 (TYP 2) 120 (TYP 2) 80 (TYP 4) 80 (TYP 4) 120 (TYP 2) PHASE 2 PHASE 2 / 5 / 24x24 330 24x24 190 80 24x24 85 330 1ST FLOOR DEMO PLAN HVAC SCALE: 1/8" = 1' -0" / 6 ' 24x24 A 85 ABANDONED EQUIPMENT. OUTSIDE AIR INTAKE. RADIANT CEILING PANEL. RETURN AIR BOOT ABOVE CEILING. DUCT CONFIGURATION COULD NOT BE VERIFIED. PRESUMED LOCATION OF ZONE DAMPER. COULD NOT BE VERIFIED. NO T'STAT FOUND FOR THIS ZONE DAMPER. 220 24x24 100 130 230 24x24 350 24x24 A 24x24 100 250 250 24x24 100 (12x24 (TYP 4) 24x24 100 80 (TIP 3 ) 24x24 250 r 60 (TYP 4) 24x24 6x48 45 24x24 250 24x24 TRANSFER 24x24 210 24x24 230 24x24 190 24x24 220 6x48 310 REVIEWED FOR CODE COMPLIANCE APPROVE JUN 2 5 2009 City of Tukwila BUILDING DIVISION I Nlo'7-cY7(o CITY RECEIVED JUN .1 2009 PERMIT CENTER MacDonald - Miller FACILITY SOLUTIONS 7717 Detroit Avenue SW Seattle, WA 98106 Phone: 206- 763 -9400 Fax: 206- 767 -6773 www.macmiller.com WA Li No: MACDOFS980RU GATEWAY BLDG 7 PHASE 2 12720 GATEWAY DR S TUKWILA WA 98168 1ST FLOOR DEMO PLAN - HVAC ENGINEER: C LEE CHECKED BY: B GEZON CAD: P MILLER LAST REVISED: 05 -21 -08 DATE PLOTTED: 05 -21 -08 ISSUE DATE: 05 -22 -08 DRAWING NUMBER: E - 0182 - 7386215 -00 ISSUED FOR CONSTRUCTION SHEET NUMBER: DM2.01 co O O \ ' 'GF 44x20_ 1 0x.'1 0; 16x16 RA ANT -131 WT -134 24x24 ) WT -102 WT -103 130 6x48_ - WT - 1'15 VVT -i-1 16 IT'STAT -251 24x24 100._._- 24x24 600; 24X24 WT--105 I 180 22x18 140 VVT- 1081_ • ? 104 r sTAI =05 24k24. 24x24 24x24 24x24 490 24x24 1 120 24x24 ` y 380 1_ ._._ TAT -• 20x12 RA 9' - AFF T'STAT-1 81 140 S�� WT -11 24x24. 24x24 T'STAT-03 18x1.8 :170 IT' STAT - -20E 1T'STAT =191 ECU-1'01 24x24 12x24 540 - ` 160_ 24X24 24x24 240 2x24 24x24 12x24 FCU -1103 ECU-104 IT'STAT -081 (T'STAT -071 PF, A 12x24 8: (TYP 4 N F - 1- 8'0__ (TYP_..2 I- VUT- 1.24 _ .I 120 SA DA .•'N 0 ATEH -80' a EXHAUST CFM,I FIE D ER1FY TOILET RM S I PP Y :;DUCT... (TYP.._2) 100 12x12 I T'STAT -211 24x24 24x24 150 - --- 24x24 -1 40 201 (TYP 2 F 144 EA V 6x48 300 A 24x24 VVT -114 24x24 1401 80 (TYP 4) 0 6x48 I WT -104 6x48 012x24 50 6x48 90 6x48 A 6x48 1.0.0. 24x24 24x24 12x24 }V T -105A} 4 144 RA 18x18 TRANSFER 6x48 12x24 [ 12x24 MT 6" AFF \ 40 60 IT'STAT -361 VVT -1 10 UVT -106 1._VVT -107 100 SA 24x24 IT'STAT -281 X48 ' 84 M. ris he, 6x6 �� ® � 50 4... "giV a t�,.� 1!�11k VVT— �� I "11 ---- -► IrS x 4 ® ' � 1i5 1 m Ewald! ,B 1y . VV LI122 24x 4 _< T'STAT 291 IT'STAT -321 45> 24x24 24x24 310 80 (TYP 6) 0 24x12 (TYP 2 24x24 410 ' A _ 80 (TYP 3) 80 (TYP 3) 100 (TYP 4) 80 (TYP 4) 100 (TYP 3) TYP 4) TYP 3) 12x24 (TYP 4) 0 12x24 (TYP 4) 2-4x24 -- j 80 (TYP 4) 24x24 310 24x24 24x24 170 R 24x24 A 24x24 A 24x24 170 12x24 TRANSFER (TYP 3) 80 (TYP 5) 330 24x24 /A 24x24 16x16 EA UP 24x24 110 (TYP 4) 24x24 600 (TYP 2) 120 (TYP 2) 80 (TYP 4) 24x24 600 (TYP 2) 120 (TYP 2) 80 (TYP 5) 24x24 230 (TYP 4) 24x24 600 (T 2) 80 (TYP 4) 80 (TYP 4) 24x24 190 (TYP 4) 120 (TYP 2) 24x24 600 (TYP 2) 12x24 (TYP 2 PHASE 2 6x48 300 230 4) \$ PHASE 2 , 24x24 24x24 190 80 330 LT 330 1 ST FLOOR PLAN - HVAC SCALE: /s = 1' -0 24x24 /\ 24x24 85 ABANDONED EQUIPMENT. OUTSIDE AIR INTAKE. RADIANT CEILING PANEL. RETURN AIR BOOT ABOVE CEILING. DUCT CONFIGURATION COULD NOT BE VERIFIED. PRESUMED LOCATION OF ZONE DAMPER. COULD NOT BE VERIFIED. NO T'STAT FOUND FOR THIS ZONE DAMPER. 24x24 , 24x24 0 24x24 , 24x24 24x24 100 130 70 100 100 24x24 6x48 6x48 24x24 0 24x24 220 0 230 • 350 250 250 12x24 (TYP 4) 24x24 100 24x24 24x24 80 REVIEWED FOR CODE ! PLIANCE APPROVED JUN 2 5 2009 City of Tukwila BUILDING DIVISION 6x48 45 24x24 250 24x24 TRANSFER 24x24 210 24x24 230 24x24 190 24x24 220 A MO9LO7 CITY OF TUKWILA JUN 1;x:7 2009 PERMIT CENTER MacDonald - Miller FACILITY SOLUTIONS 7717 Detroit Avenue SW Seattle, WA 98106 Phone: 206- 763 -9400 Fax: 206 - 767 -6773 REVISIONS: www.macmiller.com WA Lic No MACDOF CD— PERMIT SET DATE 05 -22 -08 GATEWAY BLDG 7 PHASE 2 12720 GATEWAY DR S TUKWILA WA 98168 1ST FLOOR PLAN - HVAC ENGINEER: C LEE CHECKED BY: B GEZON CAD: P MILLER LAST REVISED: 05 -21 -08 DATE PLOTTED: 05 -21 -08 ISSUE DATE: 05 -22 -08 DRAWING NUMBER: E -0182- 7386215 -00 ISSUED FOR CONSTRUCTION SHEET NUMBER: TM2RO1 0 0 I- N co N) cn H 0 C z w O L7 Th 80 (TYP 2) r K 80 (TYP 4) 90 (TYP 4) 90 (TYP 5) 24x24 TRANSFER 80 90 (TYP 6) 48x24 (OPEN RETURN) y0 �r✓�' r/ pf✓amLrtr7r/rzz7LUaaYOacac/aaa' % // / : �laril% uvu��7lrrla7riirlar %rLaaac;;;u,i i710. F!allL7 z7rar!'O7.//2>'1G %LL „ GL /fin + / I T'STAT -4 I N N 90 (TYP 3) 1- 0 x L 12x24 a7/ % /! / , /, / p a 6 6 r✓ % M79A ✓ :'727;2272=02. !!Of // raO9f %a,7 ...23 rf lrZ %i"LJ!/,JIIrP/ 'L'!/Z. S79 L%a/G L /1 % 722 IT'STAT -50 1 eb- ia/a ��rarrca ” 7�zr /Lr'7,7iarrrr� rrinaa zo�:zza<� � CAPPED C7. d 12x24 (TYP 2) 24x24 CAPPED T'STAT-46I OFF 80110M OF DUCT TEE 22x22 RA 180 (TYP 2) 24x24 18x18 EXH DN (T I T'STAT -5t11I 38x20 SA 100 18x18 EXH UI 1.2x240 1 -49 C. L 80 a� 10' -5" 0 AFf g 0 C. L. 11' -0" AFF /llflf /fa /r %aaal./GGr, 7276. 1.. / /'I6 72r01.7a .2AS.757/ /527 / :!/e3. 7 1 / .ozz/zzv:,,/ , dzof a' L7/ na., 7 ✓ra_i/a4717 / "'lOLl:7aa/.,'/zar. j/72Aalr/Aaa aaJZrraa,://l///L7,✓//27C 60 r:/img271i 6rlfl /rL277La!! /1lGlLrLr87L z/a/rr/„'.� '//a7..z !a!%7r acv TSTAT-42 24x12 IT'STAT -441 DUCTS DUCTS 38x2a 12, •12 ' O 6g 10 EXH DN 0 i fr7 16x10 EXH 12x24 (TYP 2) 140 _ - R - -mm.7 ze,7a,L car,: Pfd .._.._.. 7aa/ao /4z7llLZ6/lrm2a%7/af.. / aa,%aaal.':Olala!"7L^OafalaG /!r.,O/74ar✓727 ' VIIVT -201 0 IT'STAT -601 12x24 C.L. R 10' AF T'STAT -61I '//i/(,aaara/Gr///LL,:✓am" a/ v.7a/aJ7/GZ/,a 12x24 24x24 fV 120 TYP 2 A P 0 (� 24x24 24x24 80 Q 80 Ol.: Zl J'' /JJ06 l(///4/7//r// /n4/ Off/✓//, '/✓.r707/l/ /.%/J,.,.,/7/ZliZL 77f//A/!/OTi/l. FF ^ �-- ='i % 80 (TYP 3) ( 6x48 /',04gg7, % ///rrrM'S' WT-212 24x24 24x24 bx4t5 140 � 0 � I ( AVIA O 50 x48 MIN 40 — rsTAI — //1 r /raai:�f 24x24 140 100 24x24 �-14o 7azo- /,rL�/"' %. % /L%/ TYP 2 / /for / ✓/a///r7 u//G�./O% .0.02 "/7 !ua/., '/ OrlL7faArf .�//frrrvrnllrof/!IL'd 18x18 TRANSFER 44 , 7 - M T 6" AFF 260 SA 1PIP - 1 F 120 140 l002✓�77//00 ,// f /,4 i7 i%0I%7Vir%/./9.0LE :/ ///Za "o ' / 2 ''2 10 - 6" AFF 140 J707070/0G%0/cJ07G700/ //!%7 070700r✓ZO. %O0L%l.P3Y/! /.0OJ O 12x24 380 24x24 IT'STAT -651 24x24 B.O.D. A FF 4 ,LZ:.�%, ,a , {VVT -203} 0 A 24x24 170 Atk 0 24x24 A 170 44x20 S, TR if�� CTS rr i!'/.// ./O ,Eo <; x © 6x48 TR Iu\ 280 DUCT 6x48 120 SA FCU -201 24x24 12x24 /7207;097 24x24 v#J 24x24 rira2L7 : , 44 !62'a!1/Z7a7 Lzn f 07//07./SF, i � i - :� �ir�ilad��Ti� ! //i ill AFF 4 v_ Q fr, , 1 a O wl xx N ri . X 0 r ¢ I 14� (TYP 3) ' �� 12x24 (YP 3,,, ,r"j7,":"",zg zr✓zrz," % / /7aafaar/aafa zaiaff ��-- � � _�IU>... TRUNK � ® 4 .' i . o DUCTS UP 8 44x2 M /�Q -220 k'!� � TRUNK 7 4 { 140 SA ■ 140 W1 -209 L C.L. 0' -6" 12x24 - v'' /rG•i// 0../.,'i3.d'/r!?.!%,rv/ Liz rr././O 7aYMY.ar/4 //. Tr 6x48 320 /\ 24x24 24x24 TRANSFER (TYP 2) IT'STAT -691 VAV -201 0 24x24 24x24 T IT'STAT -701 Y IJ � A P S r, 7/ c 9// a aL 1 -7277/1", !/ r L /! O a! L yr ar - ,Z2624 i r r a r f/ a 0.M2,2 v7raa!a /oaa,z- r,27aaaroor 77 80 CAPPED : /� ✓vloaa /✓�r�a! aL�laral ,W ! . /i/ /irk 2 4x24 k 0 _ r Ar 060 __p o u 24x24 C. L. 10' -2" 0' 7 0.1 a7// IJ//% C✓ .'!L %! % %lraHO!"%f '" !!!LGla///eG 4S/;/;OZ 7ra/':7%: W./.1G /r /!!I: 1G %!!/G.w' X120 120 80 ' i F 2i%iG%r,0/, Gal.0ir 7!C:.:J%a 'ry0r , 7./ !:Li,'.'r.C'i✓/ L .%r .Oi%!4Z, 2%!0a✓.r722/22,0=277,2702F2 - .7" /.. MS7 2E V- 6 G7//LLLZ.07/aM2 80 (TYP 8 // O 80 (TYP 4) PHASE 2 ;48 6x48 PHASE 2 6x48 6x48 24724 160 F TES: R 12x24 210 24x24 � 12 R X24 11 21x21 CONTROL POWER TRANSFORMER FOR PARKER /CARRIER CONTROLS, ABOVE CEILING. DIFFUSER NOT MOUNTED CORRECTLY. AIR DISCHARGED INTO CEILING CAVITY. DUCT NOT SECURELY FASTENED TO GRILLE. DIFFUSER NOT CONNECTED. RETURN TO CEILING SPACE. FAN COIL UNIT. MOUNTED ABOVE CEILING SPACE. FAN POWERED VAV UNIT. DUCT CONFIGURATION COULD NOT BE VERIFIED. GRILLES CONNECTED TO FAN COIL UNIT IN SHIPPING /RECEIVING AREA CEILING SPACE. (SEE FLAG NOTE 5) GRILLE CONNECTED FROM B01IOM OF DUCT. 10 60 TON MONITOR T -STAT. 120 SA DUCT BETWEEN RISERS TO SA DUCT. 2ND FLOOR DEMO PLAN HVAC SCALE: %6" 6x48 110 24x24 166 2x24 120 EXH DUCT THRU ROOF 24x24 145 N T CONNECTED x24 FILTER GRILLE 4x24 00 24x24 145 4x24 (TYP 3) 24x -24 110 24x24 180 24x24 180 6x48 105 .11/I 6x48 ' 75 REVIEWED FOR CODE COMPLIANCE APPROVED JUN 2 5 2009 City of Tukwila BUILDING DIVISION MOO (p RECEIVED CITY OFTUKWILA JUN -1.7 2009 PERMIT CENTER MacDonald - Miller FACILITY SOLUTIONS 7717 Detroit Avenue SW Seattle, WA 98106 Phone: 206 - 763 -9400 Fax: 206- 767 -6773 www.macmiller.com WA Lic No: MAODOF I EXPIRES 7/6/9'O CD PERMIT SET REVISIONS: 05 -22 -08 DATE GATEWAY BLDG 7 PHASE 2 12720 GATEWAY DR S TUKWILA WA 98168 2ND FLOOR DEMO PLAN - HVAC ENGINEER: C LEE CHECKED BY: B GEZON CAD: P MILLER LAST REVISED: 05 -21 -08 DATE PLOTTED: 05 -21 -08 ISSUE DATE: 05 -22 -08 DRAWING NUMBER: E- 0182 - 7386215 -00 ISSUED FOR CONSTRUCTION SHEET NUMBER: DM2.02 CO 0 0 N 8x8 270 /1,/1O,!I %/O/rylI7/O %/O/%i.'1///O///4,/// 29 //,?.%I.%/,'6/.%!(::G'.:1G!!! !'O /! CG3T /CG?YO!/! /:.41 ////.f/Al.0f(.%C.r G7/7OL7OG//f(G'O.'Oi A,// F7/:Y/67/7#AV / s^/. MO/GJO/.Ji7!.€02074.W. l/O//110."J%l//LZW./4Tir !Or?7v'7/llJ ' lI O. 1L? �.%/.: /9/u'uM...4 ^/!9224./ Z19 !OO.. 7/'L•Z %!GL IT -501 140 (TYP 4) J 12x24 (TYP 4) CAPPED / 24x24 24x24 1 W1 -2271 I 124 SA 2 0 1 I c - 18x18 .._ P EXH. DN '-LZ 4w4,7/%i'inrri%7lv'9G:MOP AFF IT'STAT -46I U "7/. r!/i/i/cllcrcr roi/!!e a /ryll4 . . CAPPED 24x24 ■ TRANSFER n zzoz zz7 38x20 SA 100 18x18 EXH 24x24 210 22x22 RA 184 (TYP 2) S' G 4111$01- 1 4 A �f!!/ LO'/ 7/ rr/!//. 2r7rr!// TlO1!! '.'/i/!OIllllrr7/.?l!l?!/Il17ir 24x24 a ///',1/1052 lrliO /O/7/O /%O 9 // J' 1r JiF1 bg47,/! /, _% /o/7/J/O/nn1/// ro .... . . lrr/ll�: iro�vl.!//� �Il /.a//Za7l�7r/nm /Olo/1/ //ml/O /� "O � ':r� 1 / I G% O, Y ///b%i7//.///7rG%1/.%J//r /mi,.✓ 140 RA 8x: 240 WT -237 1 38x18 1SA 24x24 24x24 24x24 100 18x18 TRANSFER MT 6" AFF. 24x24 140 RA ST T -49i 38x18" RA 24x12 80 (TYP 4) 8x8 180 TR Iji1ic .. DUCTS UP `1'610 EXH DN 00 i X 116x1 ` 01X1r ; 12x24 (TYP 2) 100 C.L. / //O Y! %lJG/.%%l .YIO////OJIOfL ✓/ 110. ` ` f „ r//// 1.'✓. 7!/?/.. O/!/./ iG::/ 2/ P/ 6.'!,% G/ %/!/G./:✓rl /////.9 ✓ /.. 1 24 — IT -481 , - !/IZOE?//.O//,-£�.2L.!: :!.%/!G /.!6,°.'6, :%G ,lZ%//.i. '.%i. d✓':4rrG7rr/O,. Di.mr!rOOM%', 38x2tA -� 12x,,AL CAP 16 /te ; SL /O! r/ / r I L z � / / O / / /r! / 7 / O/!V "Z".. r'7 °' ..0..'�/iax¢ I0=0— err /r/�:f ! %O67//.W174 y70a r/2',474 r6 %7O/L BAG4NC= fi'Cl'I zr /o /�! UCTS OF EXHAUST CFM. FIELD VERIFY TOILET RM SUPPLY DUCT (TYE, 2) 12x24 24x24 TT'STAT -601 X 120 SA 80 3) 12x24 T'STAT -611 12x24 120 0 WT -215 WT -214 24x24 WT -217 VVT - 213 4111164. FCU -201 d✓/raraa,r97/ rrmo/7�r/v. .47.41V47.07/4/14944: ' 12x24 24x24 160 W 150 140 24x24 80 W80 12x24 ns: z///zitavlom,igevwir✓zeolo Odiizozem i i CAP 1 2 0 5 A I /0//00/0/OG7Ji.✓zLGMP. //O/ .9. .W.6"/7 // //////U//f'.'7/.X ..- ✓//G./%LfrM4 — _0 1 11 1 � VVT -2121 24x24 +JJrn% rri919999/ r /On,'/ % ;ra 24x24 24x24 ,. /..., /// 4 r/rzz !/ - ✓ omarlo�fa 24x24 12x24 24x24 arOrrim �/!. 24x24 0 80 10! / 0 % l.. OO / " M /i G �O / / O 24x24 y a 0 © 24x24 180 O 12x24 380 6x48 44x20 Si■ '?% / 4G%/'/L/.% IG!// 1m' I!/ Tl/lA./'57! /r! / / /. % %✓z regfc, :/ ..a.A !/ v./z o/! /! / 2SI?/!/%LD %riff,'!!!/r/!47,. /" „fi 12x24 1 120 SA AFF � I• r' I 200 " 1 j � r 24x24 WT -221 80 (TYP 2 120 RA a DN /9\ ./ O/ ff,'"!,fi/Olf i O/rG/7//OOl/ V 24x24 �' 140 105 24x24 24x24 170 TRUNK DUCTS 9,./04=j19:7449. 6x48 TR 6x48 r/.GZ.Z6 srm /raG P N111111.1 rzr a��hn1 DUCTS UP 44x20 �� J . T .a 80 24x24 24x 4 1001 24x24 4/ (` ,92/9//!%1/// Oa /Qe 120 EXH DUCT THRU ROOF 24x24 TRANSFER (TYP 2) 24x24 0 90 24x24 VAV -201 T. TTT/1 24x24 0 6x48 �0 T'STAT- 24x24 '!7O/OOOO!!,O TT'STAT -701 fe.M9/r/O/O62z : 'STAT -73) 24x24 d7/G224 leAr4 12x24 24x24 260 80 (TIP 2) MP / � 84 F , 6x48 210 540 90 (TYP 4) 6x48 90 (TYP 5) 6x48 70 6x48 230 90 (TYP 6) 6x48 360 TYP 3 TYP 4) 6 x48 00 (TYP 5 24x24 TRANSFER (TYP 5) 048x24 (OPEN RETURN) 8x8 ifs 90 (TYP 3) 0 L>r=411 6x48 (TYP 3) 8x8 IVVT -226j 260 100 %!/v'J' ..7M // / /GG702 // /!r!/!/r/!//rrOl!O , 71!r7 6x48 260 (TYP 4 TYP 4 80 (TYP 8) 8x8 260 6x48 280 6x48 290 80 (TYP 4) PHASE 2 TYP 4) TYP 4) TYP 4) K SHEET NOTES: 01 FIELD LOCATE T -STAT FOR WT -228 AND RELOCATE IF NECESSARY. O PROVIDED DUCTED RETURN ON PARALLEL VAV BOX. / 270 6x48 0 PHASE 2 i U%r7// %///!.✓ i i fH SCALE: 1 / 0 0 0 0 DUCT NOT SECURELY FASTENED TO GRILLE. DIFFUSER NOT CONNECTED. RETURN TO CEILING SPACE. FAN COIL UNIT. MOUNTED ABOVE CEILING SPACE. FAN POWERED VAV UNIT. >- DUCT CONFIGURATION COULD NOT BE VERIFIED. x24 FL ""` G e;Mw TE 4x24 CONTROL POWER TRANSFORMER FOR PARKER /CARRIER CONTROLS, ABOVE CEILING. DIFFUSER NOT MOUNTED CORRECTLY. AIR DISCHARGED INTO CEILING CAVITY. GRILLES CONNECTED TO FAN COIL UNIT IN SHIPPING /RECEIVING AREA CEILING SPACE. (SEE FLAG NOTE 5) GRILLE CONNECTED FROM BOTTOM OF DUCT. 60 TON MONITOR T -STAT. 120 SA DUCT BETWEEN RISERS TO SA DUCT. 2ND FLOOR PLAN HVAC 180 1x-21 CaNi 6x48 110 2x24 24x24 145 0 24x24 A 145 DT CONNECTED 24x24 FILTER GRILLE 4x24 4x24 (TYP 3) 24x24 10 24x24 180 24x24 180 6x48 05 6x48 5 REVIEWED FOR CODE COMPLIANCE APPROVED JUN 2 5 2009 City of Tukwila BUILDING DIVicinm 4�9O7& RECEIVED CITY OF TUKWILA JUN; .;7 2009 PERMIT CENTER MacDonald- Miller FACILITY SOLUTIONS 7717 Detroit Avenue SW Seattle, WA 98106 Phone: 206 - 763 -9400 Fax: 206 - 767 -6773 www.macmiller.com WA. L.ic No: _ MACDOFS980RU EXPIRES 7/6/ 0 CD PERMIT SET REVISIONS: 05 - 22 - 08 DATE GATEWAY BLDG 7 PHASE 2 12720 GATEWAY DR S TUKWILA WA 98168 2ND FLOOR PLAN - HVAC ENGINEER: C LEE CHECKED BY: B GEZON CAD: P MILLER LAST REVISED: 05 -21 -08 DATE PLOTTED: 05 -21 -08 ISSUE DATE: 05 -22 -08 DRAWING NUMBER: E- 0182 - 7386215 -00 ISSUED FOR CONSTRUCTION SHEET NUMBER: TM2.02 ROOF PLAN HVAC SCALE: %s TM2.0 A -A &R-EEN WALL REPLACE RTU -102 RECONNECT NEW UNIT TO E :ISTING NATURAL GAS LINE -AND ELECTRICAL SERVICE 1. NOT ALL ROOF— MOUNTED EQUIPMENT IS SHOWN. 50 TON MODEL CARRIER 48AKTO5DSQ61 1 HM. [EXISTING] CARRIER WEATHER MAKER SINGLE— PACKAGED 60 —TON ROOFTOP UNIT. MODEL# 48DF -064. SERIES# 640PA. SERIAL# Y883274. [EXISTING] REPLACE W/ 60 TON MODEL CARRIER 48A3T060DSV61 1 HM. CARRIER WEATHER MAKER SINGLE- PACKAGED ROOFTOP UNIT. MODEL# 48TJD014. SERIES# 601 QE. SERIAL# 4194G30497. [EXISTING] SCREEN WALL I RTU -101 RTU -102 SOUTH ELEVATION NO SCALE boa --o7 cp SLAB 0 N RECEIVED CITY OF TUKWILA JUN - 1 7 2009 PERMIT CENTER MacDonald- Miller FACILITY SOLUTIONS 7717 Detroit Avenue SW Seattle, WA 98106 Phone: 206- 763 -9400 Fax: 206- 767 -6773 www.macmiller.com WA Lic No: MACDOFS980RU CD— PERMIT SET 05 -22 -08 REVISIONS: DATE GATEWAY BLDG 7 PHASE 2 12720 GATEWAY DR S TUKWILA WA 98168 ROOF PLAN AND ELEVATION - HVAC ENGINEER: C LEE CHECKED BY: B GEZON CAD: D IKERD LAST REVISED: 05 -21 -08 DATE PLOTTED: 05 -21 -08 ISSUE DATE: 05 -22 -08 DRAWING NUMBER: E - 0182 - 7386215 -00 ISSUED FOR CONSTRUCTION SHEET NUMBER: TM2.03 0 0 0 u7 N CO N- I- cn z 0 0 0 0 u_ U) N I1J a_ 0 0 J Q W 0 LCD N co N) 0